This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Smokeless Combustion within a Small-Bore HSDI Diesel Engine Using a Narrow Angle Injector
Technical Paper
2007-01-0203
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Combustion processes employing different injection strategies in a High-Speed Direct Inject (HSDI) diesel engine were investigated using a narrow angle injector (70 degree). Whole-cycle combustion was visualized using a high-speed digital video camera. The liquid spray evolution process was imaged by the Mie-scattering technique. Different injection strategies were employed in this study including early pre-Top Dead Center (TDC) injection, post-TDC injection, multiple injection strategies with an early pre-TDC injection and a late post-TDC injection. Smokeless combustion was obtained under some operating conditions. Compared with the original injection angle (150 degree), some new combustion phenomena were observed for certain injection strategies. For early pre-TDC injection strategies, liquid fuel impingement is observed that results in some newly observed fuel film combustion flame (pool fires) following an HCCI-like weak flame. For late post-TDC injection strategies, strong fuel impingement is seen for injection timing close to TDC with very strong soot luminosity in the combustion chamber. However, by further retarding the injection timing smokeless combustion is possible for the post-TDC injection strategy. Typical diffusion burning occurs in the combustion chamber for certain conditions with the fuel film combustion from the first early injection. In order to obtain a smokeless combustion process for the second main injection, the pool fires for the first early pre-TDC injection must be eliminated or reduced to a great extent. Multiple injection strategy provides a promising approach to achieve low soot and low NOx combustion while keeping high fuel efficiency. Compared to the original injection angle, the narrow angle injector provides the opportunity for injection strategy optimization without liner wall wetting.
Recommended Content
Authors
Topic
Citation
Fang, T., Coverdill, R., Lee, C., and White, R., "Smokeless Combustion within a Small-Bore HSDI Diesel Engine Using a Narrow Angle Injector," SAE Technical Paper 2007-01-0203, 2007, https://doi.org/10.4271/2007-01-0203.Also In
References
- Onishi, S. Hong S. Jo Shoda, K. Do Jo P. Kato S. Active Thermo-Atmosphere Combustion (ATAC) ----- A new combustion process for internal combustion engines SAE paper 790501
- Noguchi, M. Tanaka Y. Tanaka T. Takeuchi Y. A study on gasoline engine combustion by observation of intermediate reactive products during combustion SAE paper 790840
- Najt, P.M. Foster D. E. Compression Ignition Homogeneous Charge Combustion SAE paper 830264
- Thring, R.H. Homogeneous Charge Compression Ignition (HCCI) engine SAE paper 892068
- Takeda, Y. Keiichi Na. Keiichi Ni. Emission characteristics of premixed lean diesel combustion with extremely early staged fuel injection SAE paper 961163
- Iwabuchi, Y. Kawai K. Shoji T. Takeda Y. Trial of new concept diesel combustion system---Premixed Compression Ignition Combustion SAE paper 1999-01-0185
- Helmantel, A. Denbratt I. HCCI operation of a passenger car common rail DI diesel engine with early injection of conventional diesel fuel SAE paper 2004-01-0935
- Kimura, S. Aoki O. Ogawa H. Muranaka S. Enomoto Y. New combustion concept for Ultra-clean and high efficiency small DI diesel engines SAE paper 1999-01-3681
- Yokota, H. Kudo Y. Nakajima H. Kakegawa T. Suzuki T. A new concept for low emission diesel combustion SAE paper 970891
- Hasegawa, R. Yanagihara H. HCCI combustion in DI diesel engine SAE paper 2003-01-0745
- Kook, S. Bae C. Combustion control using two-stage diesel fuel injection in a single-cylinder PCCI engine SAE paper 2004-01-0938
- Walter, B. Gatellier B. Development of the high power NADI concept using dual mode diesel combustion to achieve zero NO x and particulate emissions SAE paper 2002-01-1744
- Walter, B. Gatellier B. Near Zero Nox Emissions and high fuel efficiency diesel engine: the NADI TM concept using dual mode combustion, Oil & Gas Science and Technology- Rev. IFP 58 2003 1 101 114
- Walter, B. Monteiro L. Miche M. Gatellier B. Improvement of exhaust and noise emissions of the NADITM concept using pre-mixed type combustion with multiple stage injection 2004
- Lechner, G.A. Jacobs T.J. Chryssakis C.A. Assanis D.N. Siewert R. M. Evaluation of a narrow spray cone angle, advanced injection timing strategy to achieve partially premixed compression ignition combustion in a diesel engine SAE paper 2005-01-0167
- Dec, J.E. Espey C. Soot and fuel distributions in a DI diesel engine via 2-D imaging SAE Paper 922307 1992
- Espey, C. Dec J.E. The effect of TDC temperature and Density on the liquid-phase fuel penetration in a DI diesel engine SAE Paper 952456 1995
- Siebers, D.L. Liquid-phase fuel penetration in Diesel Sprays SAE Paper 980809 1998
- Higgins, B.S. Mueller C.J. Siebers D.L. Measurement of fuel effects on liquid-phase penetration in DI sprays SAE Paper 1999-01-0519 1999
- Shao, J. Yan Y. Greeves G. Smith S. Quantitative characterization of diesel sprays using digital imaging techniques Measurement Science and Technology 14 1110 1116 2003
- Delacourt, E. Desmet B. Besson B. Characterization of very high pressure diesel sprays using digital imaging techniques Fuel 84 859 867 2005
- Siegel, R. Howell, J.R. Thermal radiation heat transfer 3rd 581 Taylor & Francis Inc. Washington, DC 1992
- Espey, C. Dec J.E. Diesel engine combustion studies in a newly designed optical-access engine using high-speed visualization and 2-D laser imaging SAE Paper 930971 1993
- Dec, J.E. Espey C. Ignition and Early Soot Formation in a DI Diesel Engine Using Multiple 2-D Imaging Diagnostics SAE Paper 950456 1995
- Dec, J.E. Espey C. Chemiluminescence Imaging of Autoignition in a DI Diesel Engine SAE Paper 982685 1998
- Miles, P.C. The Influence of Swirl on HSDI Diesel Combustion at Moderate Speed and Load SAE Paper 2000-01-1829 2000
- Maunoury, B. Duverger T. Mokaddem K. Lacas F. Phenomenological Analysis of Injection, Auto-Ignition and Combustion in a Small DI Diesel Engine SAE Paper 2002-01-1161 2002
- Pajot, O. Maunoury B. Duverger T. Mokaddem K. Lacas F. Optical Investigation of Auto-Ignition Process in a Small DI Diesel Engine SAE Paper 2002-01-1162 2002
- Mathews, W.S. Coverdill R. E. Lee C. F. White R. A. Liquid and Vapor Fuel Distributions in a Small-Bore High-Speed Direct-Injection Diesel Engine Journal of Fuels and Lubricants 111 4 1059 1071 2002 SAE paper 2002-01-2666
- Fang, T. Coverdill R. E. Lee C. F. White R. A. Low Temperature Combustion within a Small Bore High Speed Direct Injection (HSDI) Diesel Engine SAE Paper 2005-01-0919
- Akagawa, H. Miyamoto T. Harada A. Sasaki S. Shimazaki N. Hashizume T. Tsujimura K. Approaches to solve problems of the premixed lean diesel combustion SAE paper 1999-01-0183
- Fang, T. Coverdill R. E. Lee C. F. White R. A. Liquid and Vapor Fuel Distributions within a High Speed Direct Injection (HSDI) Diesel Engine Operating in HCCI and Conventional Combustion Modes SAE Paper 2005-01-3838
- Odaka, M. Suzuki H. Koike N. Ishii H. Search for optimizing control method of homogeneous charge diesel combustion SAE paper 1999-01-0184
- Kaneko, M. Morikawa K. Itoh J. Saishu Y. A study on homogeneous charge compression ignition gasoline engines JSME International Journal 46 1 31 36 2003
- Strjkovic, B.D. Fansler T.D. Drake M.C. Sick V. High-speed imaging of OH and soot temperature and concentration in a stratified-charge direct-injection gasoline engine Proceedings of the Combustion Institute 30 2657 2665 2005