This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Dynamic Analysis of the Hydro-Pneumatic Front Axle Suspension of Agriculture Tractor
Technical Paper
2006-01-3526
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The paper considers a possibility of using a tractor front axle hydro-pneumatic suspension with single-acting cylinders and automatic level control. A study with the MSC.ADAMS simulation software has shown that such suspension combined with a preset suspension kinematic scheme on a swinging subframe does not prove itself, since it brings no improvement of the vibration level indicators and steering response of the tractor under a wide range of vertical loads. A reduction of vibration levels was observed at tractor driving modes with higher vertical loads - front implements as well as front load with rear implements. In this case, the probability of hitting bump stops and the driver's comfort are highly dependent on the damping in the suspension, defined by a controllable hydraulic restriction.
Recommended Content
Authors
Citation
Mazhei, A., Uspenskiy, A., and Ermalenok, V., "Dynamic Analysis of the Hydro-Pneumatic Front Axle Suspension of Agriculture Tractor," SAE Technical Paper 2006-01-3526, 2006, https://doi.org/10.4271/2006-01-3526.Also In
References
- DIRECTIVE 2002/44/EC OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL 25 June 2002
- Device for controlling suspension performance of a vehicle having variable axle loads Carl Freudenberg KG
- Hydro-pneumatic driven axle suspension Deere & Company
- HYDAC Corporation Diaphragm accumulators www.hydacusa.com/literature/accumulators/Diaphragm.pdf
- Rexroth Bosch Group Diaphragm-type accumulator http://www.boschrexroth.com/country_units/america/united_states/en/products/bri/Products_and_Catalogs/bosch_branded_products/hydraulics_accumulator/a_downloads/pdf_erl/1987761403-2.pdf
- MSC.Software. Using ADAMS/Tire road models
- Mechanical Vibration and Shock - evaluation of human exposure to whole-body vibration - Part 1: General requirements International Organization for Standardization Geneva
- Yi K. Hedrick J. K. Active and Semi-Active Heavy Truck Suspensions to Reduce Pavement Damage SAE Technical Series, Reprint No. 37 November 1989 http://www.uctc.net/scripts/countdown.pl?027.pdf
- Nadlinger M. Vorderachsfederung, Kabinenfederung und Sitzfederung im Praxistest Vortrag anlässlich der 59 VDI-MEG-Tagung Landtechnik 9 10 November 2001 0674_Vorderachsfederung_Kabinenfederung
- Scarlett A. J. Price J. S. Stayner R. M. Whole-body vibration: Initial evaluation of emissions originating from modern agricultural tractors Report of Silsoe Research Institute and RMS Vibration Test Laboratory for the Health and Safety Executive www.hse.gov.uk/research/crr_pdf/2002/crr02413.pdf