This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Combined Effect of Exhaust Gas Recirculation and Partially Premixed Charge on Diesel Combustion Behavior
Technical Paper
2005-24-097
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The effects of exhaust gas recirculation (EGR) cooling, in combination with a partially-premixed charge obtained by a very advanced fuel injection (early injection), on the combustion of a Common-Rail Diesel engine, have been experimentally investigated. The combustion behavior, for different injection strategies, has been analyzed as well as the emission levels. Experimental tests have been carried out on a direct injection Fiat 1929 cm3 Common Rail Diesel engine. Two different injection strategies have been investigated: the first one was obtained performing pilot and main injections only, the second one adding an early injection. The effects on engine combustion of hot and water cooled EGR have been compared with the combustion behavior without EGR, also showing the effect produced by different pilot injection timings and quantities. Results show that cooled EGR can improve both pilot and early injection combustion causing an increase in the peak values of the heat release (GHRR), and a decrease of the NOx emissions. The use of a small early injection in addition to a pilot one contributes to reduce NOx emissions, causing a reduction of the peak heat release of pilot + early injection and an increase of the peak of heat release of main injection. NOx emissions can be reduced by the increase of EGR percentage, more with cooled than with hot EGR.
Authors
- A. P. Carlucci - University of Lecce, Research Center for Energy and Environment (CREA)
- F. F. Chiara - University of Lecce, Research Center for Energy and Environment (CREA)
- A. Ficarella - University of Lecce, Research Center for Energy and Environment (CREA)
- T. Giuranna - University of Lecce, Research Center for Energy and Environment (CREA)
- D. Laforgia - University of Lecce, Research Center for Energy and Environment (CREA)
Topic
Citation
Carlucci, A., Chiara, F., Ficarella, A., Giuranna, T. et al., "Combined Effect of Exhaust Gas Recirculation and Partially Premixed Charge on Diesel Combustion Behavior," SAE Technical Paper 2005-24-097, 2005, https://doi.org/10.4271/2005-24-097.Also In
References
- Ladommatos N. Abdelhalim S.M. Zhao H. Hu Z. The Dilution, Chemical and Thermal Effect of Exhaust Gas Recirculation on Diesel Engine Emission SAE paper 961165 1996
- Abd-Alla G.H. Using exhaust gas recirculation in internal combustion engines: a review JSAE Review 43 1027 1042 2002
- Zhang, L. “A Study of Pilot Injection in a DI Diesel Engine” SAE Paper 1999-01-3493 1999
- Pierpont, D. A. Montgomery, D. T. Reitz, R. D. “Reducing Particulate and NOx Using Multiple Injections and EGR in a D.I. Diesel” SAE Paper 950217 1995
- Kimura, S. Ogawa, H. Matsui, Y. Enomoto, Y. “An Experimental analysis of low-temperature and premixed combustion for simultaneous reduction of NOx and particulate emissions in direct injection diesel engines” JER 02002 2002 3 No 4 249 259
- Takeda, Y. Keiichi, N. Keiichi N. “Emission Characteristics of Premixed Lean Diesel Combustion with Extremely Early Staged Fuel Injection” SAE Paper 961163 1996
- Hashizume, T. Miyamoto, T. Akagawa, H. Tsujimura, K. “Combustion and Emission Characteristics of Multiple Stage Diesel Combustion” SAE Paper 980505 1998
- Kimura, S. Aoki, O. Ogawa, H. Muranaka, S. Enomoto, Y. “New Combustion Concept for Ultra-Clean and High-Efficienty Small DI Diesel Engines” SAE Paper 1999-01-3681 1999
- Odaka, M. Suzuki, H. Koike, N. Ishii, H. “Search for Optimizing Control Method of Homogeneous Charge Diesel Combustion” SAE Paper 1999-01-0184 1999
- Chan, M. Das, S. Reitz, R. D. “Modeling Multiple Injection and EGR Effects on Diesel Engine Emissions” SAE Paper 972864 1997
- Montgomery, D. T. Reitz, R. D. “Effects of Multiple Injections and Flexible Control of Boost and EGR on Emissions and Fuel Consumption of a Heavy-Duty Diesel Engine” SAE Paper 2001-01-0195 2001
- Montgomery, D.T. Reitz, R. D. “Six-Mode Cycle Evaluation of the Effect of EGR and Multiple Injections on Particulate and NOx Emissions from a D.I. Diesel Engine” SAE Paper 960316 1996
- Bianchi, G. M. Pelloni, P. Corcione, F. E. Luppino, F. “Numerical Analysis of Passenger Car HSDI Diesel Engines with the 2nd Generation of Common Rail Injection Systems: The Effect of Multiple Injections on Emissions” SAE Paper 2001-01-1068 2001
- Carlucci, P. Ficarella, A. Laforgia: D. “Effects on Combustion and Emissions of Early and Pilot Fuel Injections in Diesel Engines” International Journal of Engine Research 2005 6 No. 1 43 60
- Carlucci, P. Ficarella, A. Laforgia: D. “Effects of Pilot Injection Parameters on Combustion for Common Rail Diesel Engines” SAE2003 World Congress, Detroit (Michigan), March 3–6, 2003; SAE Paper 2003-01-0700 2003 Published on SAE 2003 Transactions, Journal of Engines