This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Mars Exploration Rover Surface Mission Flight Thermal Performance
Technical Paper
2005-01-2827
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
NASA launched two rovers in June and July of 2003 as a part of the Mars Exploration Rover (MER) project. MER-A (Spirit) landed on Mars in Gusev Crater at 15 degrees South latitude and 175 degrees East longitude on January 4, 2004 (Squyres, et al., Dec. 2004). MER-B (Opportunity) landed on Mars in Terra Meridiani at 2 degrees South latitude and 354 degrees East longitude on January 25, 2004 (Squyres, et al., Aug. 2004). Both rovers have well exceeded their design lifetime (90 Sols) by more than a factor of 5. Spirit and Opportunity are still healthy and continue to execute their roving science missions at the time of this writing. This paper discusses rover flight thermal performance during the surface missions of both vehicles, covering roughly the time from the MER-A landing in late Southern Summer (aereocentric longitude, Ls = 328, Sol 1A) through the Southern Winter solstice (Ls = 90, Sol 255A) to nearly Southern Vernal equinox (Ls = 160, Sol 398A).
This paper describes the MER rover thermal design, its implementation and performance on Mars. The rover surface thermal design performance was better than pre-landing predictions. The very successful thermal design allowed a high level of communications immediately after landing without overheating and required a minimal amount of survival heating in the dead of winter.
An analytical thermal model developed for the rover was used to predict surface operations performance. A reduced-node version of this model was integrated into the mission planning tool to achieve the proper balance between: 1) a desired science and communications operating profile, 2) the energy available from the power system and 3) requirements to maintain rover hardware within prescribed temperature limits. One of the more challenging thermal problems during surface operations, predicting the performance of actuator and camera electronics warmup heaters, was automated by using heater lookup tables that were periodically updated based on flight telemetry.
Specific MER rover thermal flight experiences are discussed in this paper. Lessons learned and suggestions for improving future Mars surface vehicle designs are presented.
Recommended Content
Authors
- Keith S. Novak - Jet Propulsion Laboratory, California Institute of Technology
- Charles J. Phillips - Jet Propulsion Laboratory, California Institute of Technology
- Eric T. Sunada - Jet Propulsion Laboratory, California Institute of Technology
- Gary M. Kinsella - Jet Propulsion Laboratory, California Institute of Technology
Topic
Citation
Novak, K., Phillips, C., Sunada, E., and Kinsella, G., "Mars Exploration Rover Surface Mission Flight Thermal Performance," SAE Technical Paper 2005-01-2827, 2005, https://doi.org/10.4271/2005-01-2827.Also In
References
- Haberle, R.M. Joshi, M Murphy, J. Barnes, J. Schofield, J.T. Wilson, G. Lopez-Valverde, M. Hollingsworth, J. Bridger A.F.C. Schaeffer J. 1999 General circulation model simulations of the Mars Pathfinder atmospheric structure investigation/meteorology data, Journ. Geophys. Res. 104 8957 8974
- Kaplan, D. “Environment of Mars, 1988,” NASA Technical Memorandum 100470 Lyndon B. Johnson Space Center Houston, TX October 1988
- Lankford, K. “Paraffin Actuated Heat Switch Flight Qualification,” 13 th Annual Spacecraft Thermal Control Technology Workshop The Aerospace Corporation Los Angeles March 6-8 2002
- Novak, K.S. Pauken M.T. Sunada, E. Birur, G. “Wax Actuated Heat Switch Development,” 13 th Annual Spacecraft Thermal Control Technology Workshop The Aerospace Corporation Los Angeles March 6-8 2002
- Novak, K. Phillips, C. Birur, G. Sunada, E. Pauken, M. “Development of a Thermal Control Architecture for the Mars Exploration Rovers,” Space Technology Applications International Forum 2003 Albuquerque NM February 2003
- Pauken, M. Kinsella, G. Novak, K. Tsuyuki, G. “Mars Exploration Rover Thermal Test Program Overview,” Proceedings of the International Conference on Environmental Systems Paper 04ICES-036 Colorado Springs, CO July 2004
- Squyres, S.W. et al. “The Spirit Rover's Athena Science Investigation at Gusev Crater, Mars,” Science 305 August 6 2004
- Squyres, S.W. et al. “The Opportunity Rover's Athena Science Investigation at Meridiani Planum, Mars,” Science 306 December 3 2004