This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
An Investigation into the Emissions Reduction Performance of an SCR System Over Two Years' In-Use Heavy-Duty Vehicle Operation
Technical Paper
2005-01-1861
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Increasingly stringent oxides of nitrogen (NOx) and particulate matter (PM) regulations worldwide have prompted considerable activity in developing emission control technology to reduce the emissions of these two constituents from heavy-duty diesel engines. NOx has come under particular scrutiny by regulators in the US and in Europe with the promulgation of very stringent regulation by both the US Environmental Protection Agency (EPA) and the European Union (EU). In response, heavy-duty engine manufacturers are considering Selective Catalytic Reduction (SCR) as a potential NOx reduction option. While SCR performance has been well established through engine dynamometer evaluation under laboratory conditions, there exists little data characterizing SCR performance under real-world operating conditions over time.
This project evaluated the field performance of ten SCR units installed on heavy-duty Class 8 highway and refuse trucks. Additionally, five of these vehicles were operated with passive diesel particulate filters (DPFs) in tandem with the SCR units to further characterize the emission reduction capabilities of combining these technologies. Three of these vehicles were selected and comprehensively tested on a heavy-duty chassis dynamometer for criteria pollutants and ammonia (NH3). Testing was performed in two phases, the first after one year of in-use operation, and again after a second year.
The SCR units performed well with no deterioration in NOx performance after significant mileage accumulation. On average, NOx reductions after two rounds of testing were between 80% and 90%.
Hydrocarbons (HC) and carbon monoxide (CO) emission reductions met expectations based on previous test cell results [1,2,3]. PM emission reductions were below expectations possibly due to installation of non-degreened DPFs, sulfate-make, and/or system deterioration. It is difficult to draw conclusions from PM results without repeat of tests and more in-depth post-test PM analysis.
Recommended Content
Authors
Topic
Citation
Block, M., Clark, N., Wayne, S., Nine, R. et al., "An Investigation into the Emissions Reduction Performance of an SCR System Over Two Years' In-Use Heavy-Duty Vehicle Operation," SAE Technical Paper 2005-01-1861, 2005, https://doi.org/10.4271/2005-01-1861.Also In
Diesel Exhaust Emission Control and Modeling on CD-ROM from the SAE 2005 World Congress
Number: SP-1981CD; Published: 2005-04-11
Number: SP-1981CD; Published: 2005-04-11
References
- Fritz, N. Mueller, R. Zuerbig, J. Mathes, W. “On-Road Demonstration of NOx Emission Control for Diesel Trucks with SINOx™ Urea SCR System SAE Paper No. 1999-01-0111
- Miller, W.R. Klein, J.T. Mueller, R. Doelling, W. “The Development of Urea-SCR Technology for US Heavy-duty Trucks” SAE Paper No. 2000-01-190
- Scarnegie, B. Miller, W. Ballmert, B. Doelling, W. Fischer, S. “Recent DPF/SCR Results Targeting US2007 and Euro 4/5 HD Emissions SAE Paper No. 2003-03FL-133 2003
- Wang, W. Gautam, M. Sun, X. Bata, R. Clark, N. Palmer, M. Lyons, D. “Emissions Comparisons of Twenty-Six Heavy Duty Vehicles Operated on Conventional and Alternative Fuels,” SAE Paper No. 932952 1993
- Clark, N. Gautam, M. Bata, R. Lyons, D. “Design and Operation of a New Transportable Laboratory for Emissions Testing of Heavy-Duty Trucks and Buses,” Int. Journal of Vehicle Design: Heavy Vehicle Systems 2 3 4 285 299 1995
- Wang, W. Bata, R. Lyons, D. Clark, N. Palmer, M. Gautam, M. Howell, A. Rapp, B. “Transient Response in a Dynamometer Power Absorption System,” SAE Paper No. 920252 1992
- Code of Federal Regulations, Title 40, Part 86, Subpart N “Protection of Environment,” US Government Printing Office 1998
- Wang, W. Gautam, M. Sun, X. Bata, R. Clark, N. Palmer, M. Lyons, D. “Emissions Comparisons of Twenty-Six Heavy Duty Vehicles Operated on Conventional and Alternative Fuels,” SAE Paper No. 932952 1993
- Letavec, C. Uihlien, J. Vertin, K. Chatterjee, S. Hallstrom, K. Wayne, W.S. Clark, N.N. Lyons, D.W. Chandler, K. Coburn, T. “Year-long Evaluation of Trucks and Buses Equipped with Passive Diesel Particle Filters” 2002 SAE Transactions: Journal of Fuels & Lubricants 111 242 266