This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Examination of a Heavy Heavy-Duty Diesel Truck Chassis Dynamometer Schedule
Technical Paper
2004-01-2904
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Repeatable measurement of real-world heavy-duty diesel truck emissions requires the use of a chassis dynamometer with a test schedule that reasonably represents actual truck use. A new Heavy Heavy-Duty Diesel Truck (HHDDT) schedule has been created that consists of four modes, termed Idle, Creep, Transient and Cruise. The effect of driving style on emissions from the Transient Mode was studied by driving a 400 hp Mack tractor at 56,000 lbs. test weight in fashions termed “Medium”, “Good”, “Bad”, “Casual” and “Aggressive”. Although there were noticeable differences in the actual speed vs. time trace for these five styles, emissions of the important species oxides of nitrogen (NOx) and particulate matter (PM), varied little with a coefficient of variation (COV) of 5.13% on NOX and 10.68% on PM. Typical NOx values for the HHDDT Transient mode ranged from 19.9 g/mile to 22.75 g/mile. The Transient mode which was the most difficult mode to drive, proved to be repeatable. Measurements using the Idle mode showed that engine auxiliary loads can affect run-to-run repeatability. Air conditioning and alternator loads, which the driver can control, affect emissions. There is also variability of distance specific emissions from run-to-run in the Creep mode, due to auxiliary loads and due to the small distance that is traveled during the mode.
Recommended Content
Authors
Citation
Clark, N., Gautam, M., Wayne, W., Riddle, W. et al., "Examination of a Heavy Heavy-Duty Diesel Truck Chassis Dynamometer Schedule," SAE Technical Paper 2004-01-2904, 2004, https://doi.org/10.4271/2004-01-2904.Also In
Emissions Measurement and Testing, Advanced Catalysts and Substrates, and Diesel Gaseous Emissions
Number: SP-1899; Published: 2004-10-25
Number: SP-1899; Published: 2004-10-25
References
- KIHARA, N. , TSUKAMOTO, T. , MATSUMOTO, K. , ISHIDA, K. , KON, M. , and MURASE, T. , “Real-time On-Board Measurement of Mass Emission of NOx, Fuel Consumption, Road Load and Engine Output for Diesel Vehicles,” SAE Paper 2000-01-1141 2000
- GAUTAM, M. , THOMPSON, G.J. , CARDER, D.K. , CLARK, N.N. , SHADE, B.C. , RIDDLE, W.C. and LYONS, D.W. , “Measurement of In-Use, On-Board Emissions from Heavy-Duty Diesel Vehicles: Mobile Emissions Measurement System” SAE Fall Fuels & Lubricants Meeting San Antonio, TX 2001 SAE Paper 2001-01-3643
- CLARK, N.N. , LYONS, D.W. , BATA, R.M. , GAUTAM, M. , WANG, W.G. , NORTON, P. , and CHANDLER, K. , “Natural Gas and Diesel Transit Bus Emissions: Review and Recent Data” SAE Truck and Bus Conference Cleveland, OH Nov. 1997 SAE Paper 973203
- YANOWITZ, J. , GRABOSKI, M.S. , and MCCORMICK, R.L. , “Prediction of In-Use Emissions of Heavy-Duty Diesel Vehicles from Engine Testing” Environ. Sci. Technol. 2002 36 270 275
- DIETZMANN, H. E. and WARNER-SELPH, M. A. , “Comparison of Emissions From Heavy-Duty Engines and Vehicles During Transient Operation” ASME Ppaer 85-DGP-10
- NINE, R.D. , CLARK, N.N. , DALEY, J.J. and ATKINSON, C.M. , “Development of a heavy-duty chassis dynamometer driving route” Proc. Inst. Mech. Engrs. Part D., Jour. of Automobile Eng. 1999 213 561 574
- CLARK, N.N. , TEHRANIAN, A. , NINE, R.D. , and JARRETT, R. , “Translation of Distance-Specific Emissions Rates between Different Chassis Test Cycles using Artificial Neural Networks” SAE Spring 2002 Fuels & Lubricants Meeting , Reno, NV , SAE Paper 2002-01-1754
- GAUTAM, M. , CLARK, N. , RIDDLE, W. , NINE, R. , WAYNE, W.S. , MALDONADO, H. , AGRAWAL, A. CARLOCK, M. , “Development and Initial Use of a Heavy-Duty Diesel Truck Test Schedule for Emissions Characterization” SAE Fuels & Lubricants Meeting , Reno, NV , May 2002 . SAE Paper 2002-01-1753
- AGRAWAL A. , CARLOCK M. , MALDONADO H. , CLARK, N. , GAUTAM, M. , and NINE, R. , “Progress Report for the CRC In-Use Heavy-Duty Truck Emissions Testing Project E-55/59- Regulated Emissions as a Function of Driving Cycle” 14 th CRC On-Road Vehicle Emissions Workshop San Diego, California March 29-31 2004
- U.S. Code of Federal Regulations, Title 40.
- CLARK, N.N. , GAUTAM, M. , RAPP, B.L. , LYONS, D.W. , GRABOSKI, M.S. , MCCORMICK, R.L. , ALLEMAN, T.L. and NORTON, P. , “Diesel and CNG Transit Bus Emissions Characterization by Two Chassis Dynamometer Laboratories: Results and Issues” SAE Spring Fuels and Lubricants Meeting and Exposition Dearborn, MI May 1999 SAE Paper 1999-01-1469
- SMITH, M. , SAUER, C. , and PISANO, J. , “In Situ Measurement of Low Concentration NH3 Slip in Dilute and Raw Diesel Exhaust Using Tunable Diode Laser Spectroscopy (TDLAS)” 14 th CRC On-Road Vehicle Emissions Workshop San Diego, California March 29-31 2004