This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Chemical Analysis of Exhaust Emissions from a Gasoline Direct Injection SI Engine
Technical Paper
2004-01-1445
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The exhaust emissions from a gasoline direct injection (GDI) engine were sampled using the bottle in bag method and analysed using gas chromatography/mass spectrometry (GC/MS). The GDI engine was run two times using two specially mixed fuels: a typical European base fuel containing additive and a fuel representing worst-case of European gasolines, which is a standardized European fuel, CEC RF 86-A-96, prone to form deposits. The engine was run 60 h for each fuel simulating city driving. Emissions were taken at times 0 h (at the start of the engine), 30 h and 60 h.
As a complement, particulate emissions derived from the additized base fuel were sampled on a glass filter during the first 30 h engine run. The extractable organics contained in the filter were analysed using GC/MS analysis.
Generally, the emissions were dominated by gasoline components with similar relations as in the gasoline. However, for additized base fuel at 30 and 60 h the emissions were less similar to the gasoline used. The worst-case fuel produced significantly higher levels of the measured major components compared to the additized base fuel. These higher levels may be due to a less efficient combustion producing significant amounts of unburned gasoline.
In the filter we found higher alkanes and similar oxygenated compounds originating from more and less degraded engine oil components.
Recommended Content
Authors
Topic
Citation
Owrang, F., Olsson, J., and Pedersen, J., "Chemical Analysis of Exhaust Emissions from a Gasoline Direct Injection SI Engine," SAE Technical Paper 2004-01-1445, 2004, https://doi.org/10.4271/2004-01-1445.Also In
References
- Sandquist, H. 2001 “Emission and Deposit Formation in Direct Injection Stratified Charge SI Engine” Thesis, Chalmers University of Technology 91-7291-075-5
- Sandquist, H. Denbratt, I. Ingemarsson Å. Olsson, J. O. 2001 “Influence of Fuel Volatility on Emissions and Combustion in a Direct Injection Spark Ignition Engine” SAE Technical Paper Series, SAE 982701
- Sandquist, H. Lindgren, R. Denbratt, I. 2000 “Sources of Hydrocarbon Emissions from a Direct Injection Stratified Charge Spark Ignition Engine” SAE Technical Paper Series, SAE 2000-01-1906
- Sandquist, H. Denbratt, I. Owrang, F. Olsson, J. O. 2001 “Influence of Fuel Parameters on Deposit Formation and Emissions in a Direct Injection Stratified Charge SI Engine” SAE Technical Paper Series, SAE 2001-01-05
- Cole, R. L. 1998 “Exhaust Emissions of a Vehicle with a Gasoline Direct-Injection Engine” SAE Technical Paper Series, SAE 982605
- Cole, R. L. Poola, R. B. Sekar, R. R. 1999 “Gaseous and Particulate Emissions from a Vehicle with a Spark-Ignition Direct-Injection Engine” SAE Technical Paper Series, SAE 1999-01-1282
- Crane, R. I. Rubino, L. Arcoumanis, C. 2002 “Strategies for Gasoline Particulate Emission Control-A Foresight Vehicle” Project” SAE Technical Paper Series, SAE 2002-01-1894
- Kaiser, E. W. Siegl, W. O. Henig, Y., I. Anderson, R. W. Trinker, F. H. 1991 “Effect of Fuel Structure on Emissions from a Spark-Ignited Engine” Environmental Science and Technology 25 2005 2012
- Kaiser, E. W. Siegl, W. O. Henig, Y., I. Anderson 1992 „Effect of Fuel Structure on Emissions from a Spark-Ignited Engine. 2” Environmental Science and Technology 26 1581 1586
- Kaiser, E. W. Siegl, W. O. Henig, Y., I. Anderson, R. W. 1993 “Effect of Fuel Structure on Emissions from a Spark-Ignited Engine. 3” Environmental Science and Technology 27 1440 1447
- Cheng W. K. Hamrin, D. Heywood J. B. Hochgreb, S. Min, K. Norris, M. 1993 “An Overview of Hydrocarbon Emissions Mechanisms in Spark-Ignition Engines” SAE Technical Paper Series, SAE 932708
- Dempster, N. M. Shore, P. R. 1990 “An Investigation into the Production of Hydrocarbon Emissions from a Gasoline Engine Tested on Chemically Defined Fuels” SAE Technical Paper Series, SAE 900354
- Östermark, U. 1996 “Alkylate Petrol Environmental Aspects of Volatile Hydrocarbon Emissions” Thesis, Chalmers University of Technology 91-7197-364-8
- Kameoka, A. Akiyama K. Hosoi, K. 1994 “Effect of Gasoline Composition on Exhaust Hydrocarbon” SAE Technical Paper Series, SAE 941866
- Seaton, A. MacNee, W. Donaldson, K. Godden, D. 1995 “Particulate Air Pollution and Acute Health Effects” The Lancet 345 176 178
- Donaldson, K. Beswick, P. H. Glimour, P. S. 1996 “Free Radical Activity Associated with the Surface of Particles: a Unifying Factor in Determining Biological Activity?” Toxicology Letters 88 293 298
- McAughey, J. J. Dickens, C. J. Batemen, J. R. Kwon, Y. K. 1996 “Exhaust Particulate Size Distribution: Vehicle and Fuel Influences in Light Duty Vehicles” Technical Paper Series, SAE 961980
- Graskow, B. R. Kittelson, D. B. Abdul-Khalek, I. S. Ahmadi, M. R. Morris J. E. 1998 “Characterization of Exhaust Particulate Emissions from a Spark Ignition Engine” SAE Technical Paper Series, SAE 980528
- Cadle, S. H. Mulawa, P. Ragazzi, R. A. Knapp, K. T. Norbeck, J. M. Durbin, T. D. Truex, T. J. Whitney, K. A. 1999 “Exhaust Particulate Matter Emissions from In-Use Passenger Vehicles Recruited in Three Locations: CRC Project E-24” SAE Technical Paper Series, SAE 1999-01-1545
- Dippel, B. Philippin, S. Wehner, B. Wiedenshler, A. 1999 “Measurements of Particulate Emissions of a Directly Injected Gasoline-Driven Automobile” Journal of Aerosol Science 30 Suppl. S647 S648
- Maricq, M. M. Podsiadlik, D. H. Brehop, D. D. Haghgooie, M. 1999 “Particulate Emissions from a Direct-Injection Spark-Ignition (DISI) Engine” SAE Technical Paper Series, SAE 1999-01-1530
- Wingfors, H. Sjödin, Å. Haglund, P. Brorström-Lundén, E. 2001 “Characterization and Dtermination of Profiles of Polycyclic Aromatic Hydrocarbons in a Traffic Tunnel in Gothenburg, Sweden” Atmospheric Environment 35 6361 6369
- Ho, K. F. Lee, S. C. Gloria M. Y. Chiu, G. M. Y. 2002 “Characterization of Selected Volatile Organic Compounds, Polycyclic Aromatic Hydrocarbons and Carbonyl Compounds at a roadside Monitoring Station” Atmospheric Environment 36 57 65
- Knapp, K. T. Tejada, S. B. Cadle, S. H. Lawson, D. R. Snow, R. Zielinska, B. Sagebiel, J. C. McDonald, J. C. 2003 “Central Carolina Vehicle Particulate Emissions Study” SAE technical paper, SAE 2003-01-0299
- Norbeck, J. M. Durbin, T. D. Truex, T. J. 1998 “Characterization of Particulate Emissions from Gasoline-Fueled Vehicles” Center for Environmental Research and Technology, College of Engineering, University of California Submitted to California Air Resources Board 98-VE-RT85-006-FR
- Owrang, F. Mattsson, H. Nordlund, A. Olsson, J. Pedersen, J. 2003 “Characterization of combustion chamber deposits from a gasoline direct injection SI engine” SAE Technical Paper Series, SAE 2003-01-0546
- Gairing, M. Daniel, K. 1998 “Deposit forming tendency on intake valves and in combustion chambers of gasoline engines (MB M111 engine)” Coordinating European Council for the development of performance tests for transportation fuels, lubricants and other fluids Brussels, Belgium CEC F-20-A-98
- Daniel, K. Aarnink, T. J. Gairing, M. Schmidt, H. 2000 “Combustion Chamber Deposits and Their Evaluation by a European Performance Test” SAE Technical Paper Series, SAE Paper 2000-01-2023
- Kaiser, E. W. Siegel, W. O. 1994 “High Resolution Gas Chromatographic Determination of the Atmospheric Reactivity of Engine-Out Hydrocarbon Emissions from a Spark-Ignition Engine” Journal of High Resolution Chromatography 17 264 270
- Brixie, J. M. Neilson, L. M. Kim, B. J. Severin, B. F. 1997 “Bottle in-Bag Technique for Gas Sampling with Analysis by Autoheadspace GC” Environ. Sci. Technol. 31 1224 1228
- Owrang, F. Pedersen, J. Olsson, J. 2000 “Chemical Analysis of Exhaust Emissions and Deposits from Engine Power-Plants Fuelled with Natural Gas” Report, Advanced Chemical Analysis, Chalmers Industriteknik, Chalmers Teknikpark, S-41288 Göteborg, Sweden
- Gudzinowicz, B. J. Gudzinowicz, M. J. Martin, H. F. 1976 “Fundamentals of Integrated GC-MS Part I: Gas Chromatography” Chromatographic Science Series 7 Marcel Dekker Inc. New York and Basel 295 335 0-8247-6365-3
- Peters, K. E. 2000 “Petroleum tricyclic terpanes: predicted physicochemical behavior from molecular mechanics calculations” Organic Geochemistry 31 497 507
- Seifert, W. K. Moldowan, J. M. 1980 “The Effect of Thermal Stress on Source Rock Quality as Measured by Hopane Stereochemistry” In Advanced in Organic Geochemistry 1979 (Edited by Douglas, A. G. and Maxwell, J. R. ), p 229 237 Pergamon Press Oxford
- Robinson, N. Eglinton, G. Brassell, S. C. Gowar, A. P. Parnell, J. 1986 “Hydrocarbon Compositions of Bitumens Associated with Igneous Intrusions and Hydrothermal Deposits in Britain” Organic Geochemistry 10 145 152
- El-Gayar, M. Sh. Mostafa, A. R. Abdelfattah, A. E. Barakat, A. O. 2002 “Application of Geochemical Parameters for Classification of Crude Oils from Egypt into Source-Related Types” Fuel Processing Technology 79 13 28
- Garrett, R. M. Guenette, C. C. Haith, C. E. Prince R C. 2000 “Pyrogenic Polycyclic Aromatic Hydrocarbons in Oil Burn Residues” Environmental Science and Technology 34 1934 1937
- Zakaria, M. P. Okuda, T. Takada, H. 2001 “Polycyclic Aromatic Hydrocarbon (PAHs) and Hopanes in Stranded Tar-balls on the Coasts of Peninsular Malaysia: Applications of Biomarkers for Identifying Sources of Oil Pollution” Marine Pollution Bulletin 42 1357 1366
- Maki, H. Hirayama, N. Hiwatari, T. Kohata, K. Uchiyama, H. Watanabe, M. Yamasaki, F. Furuki, M. 2003 “Crude oil bioremediation field experiment in the Sea of Japan” Marine Pollution Bulletin 47 74 77
- Barakat, A. O. Mostafa, A. R. Yaorong Qian, Y. Mahlon C. Kennicutt M. C. II 2002 “Application of Petroleum Hydrocarbon Chemical Fingerprinting in Oil Spill Investigations-, Gulf of Suez, Egypt” Spill Science & Technology Bulletin 7 229 239
- Oros, D. R. Simoneit, B. R. T. 2000 “Identification and Emission Rates of Molecular Tracers in Coal Smoke Particulate Matter” Fuel 79 515 536
- McCarthy, K. J. Emsbo-Mattingly, S. D. Stout, S. A. Uhler, A. D. 2000 “Identifying Manufactured Gas Plant Residues in Industrial Sediments” Environmental Forensics, Soil Sediments & Groundwater October/November 1
- Trier, J.C. Petch, G.S. Rhead, M.M. Fussey, D.E. Shore, P.R. 1987 “Assessing the Contribution of Lubricating Oil to Diesel Exhaust Particulates Using Geochemical Markers” SAE Technical Paper Series, SAE 874341
- Simoneit, B. R. T. 1984 “Application of Molecular Marker Analysis to Reconcile Sources of Carbonaceous Particulates in Tropospheric Aerosols” The Science of Total Environment 36 61 72
- Simoneit, B. R. T. 1984 “Organic Matter of the Troposphere-III. Characterization and Sources of Petroleum and Pyrogenic Residues in Aerosols over the Western United States” Atmospheric Environment 18 1 51 67
- Bryselbout, C. Henner, P. Lichtfouse, E. 1998 “Fossil fuel biomarkers in plant waxes as pollution parameters” The Science of the Total Environment 222 201 204
- Knapp, K. T. Tejada, S. B. Cadle, S. H. Lawson, D. R. Snow, R. Zielinska, B. Sagebiel, J. C. McDonald, J. C. 2000 “Central Carolina Vehicle Particulate Emissions Study” Final report on CRC Project E-54 Available at www.crcao.com
- Knapp, K. T. Tejada, S. B. Cadle, S. H. Lawson, D. R. Snow, R. Zielinska, B. Sagebiel, J. C. McDonald, J. C. 2003 “Central Carolina Vehicle Particulate Emissions Study” SAE Technical Paper Series, SAE 2003-01-0299
- Håkansson, Å. Strömberg, K. Pedersen, J. O. Olsson, 2000 “Combustion of Gasolines in Premixed Laminar Flames Eropean Certified and California Phase 2 Reformulated Gasoline” Chemosphere 44 1243 1252
- Owrang, F. 2000 “Methods for desorption and extraction of hydrocarbons in carbonaceous solids. Applied to chemical analysis of deposits in an advanced gasoline direct injection engine” M.Sc. Thesis Göteborg University/Chalmers University of Technology, Department of Physical Chemistry Sweden