This content is not included in your SAE MOBILUS subscription, or you are not logged in.

Influence of Trapped Residual Gasses in Air-Diluted Spark Ignited Combustion

Journal Article
03-15-06-0046
ISSN: 1946-3936, e-ISSN: 1946-3944
Published February 21, 2022 by SAE International in United States
Influence of Trapped Residual Gasses in Air-Diluted Spark Ignited
                    Combustion
Sector:
Citation: Clasén, K. and Koopmans, L., "Influence of Trapped Residual Gasses in Air-Diluted Spark Ignited Combustion," SAE Int. J. Engines 15(6):849-881, 2022, https://doi.org/10.4271/03-15-06-0046.
Language: English

References

  1. Kiyota , Y. , Akishino , K. , and Ando , H. Concept of Lean Combustion by Barrel-Stratification SAE Technical Paper 920678 1992 https://doi.org/10.4271/920678
  2. Johansson , A.N. , Hemdal , S. , and Dahlander , P. Experimental Investigation of Soot in a Spray-Guided Single Cylinder GDI Engine Operating in a Stratified Mode SAE Technical Paper 2013-24-0052 2013 https://doi.org/10.4271/2013-24-0052
  3. Quader , A.A. Lean Combustion and the Misfire Limit in Spark Ignition Engines SAE Technical Paper 741055 1974 https://doi.org/10.4271/741055
  4. Quader , A.A. What Limits Lean Operation in Spark Ignition Engines-Flame Initiation or Propagation? SAE Technical Paper 760760 1976 https://doi.org/10.4271/760760
  5. Germane , G.J. , Wood , C.G. , and Hess , C.C. Lean Combustion in Spark-Ignited Internal Combustion Engines - A Review SAE Technical Paper 831694 1983 https://doi.org/10.4271/831694
  6. Grünefeld , G. , Beushausen , V. , Andresen , P. , and Hentschel , W. A Major Origin of Cyclic Energy Conversion Variations in SI Engines: Cycle-by-Cycle Variations of the Equivalence Ratio and Residual Gas of the Initial Charge SAE Technical Paper 941880 1994 https://doi.org/10.4271/941880
  7. Szybist , J.P. , Wagnon , S.W. , Splitter , D. , Pitz , W.J. et al. The Reduced Effectiveness of EGR to Mitigate Knock at High Loads in Boosted SI Engines SAE Int. J. Engines 10 5 2017 2305 2318 https://doi.org/10.4271/2017-24-0061
  8. Doornbos , G. , Hemdal , S. , and Dahl , D. Reduction of Fuel Consumption and Engine-Out NOx Emissions in a Lean Homogeneous GDI Combustion System, Utilizing Valve Timing and an Advanced Ignition System SAE Technical Paper 2015-01-0776 2015 https://doi.org/10.4271/2015-01-0776
  9. Jung , D. , Sasaki , K. , Sugata , K. , Matsuda , M. et al. Combined Effects of Spark Discharge Pattern and Tumble Level on Cycle-to-Cycle Variations of Combustion at Lean Limits of SI Engine Operation SAE Technical Paper 2017-01-0677 2017 https://doi.org/10.4271/2017-01-0677
  10. Prucka , R.G. , Filipi , Z.S. , Assanis , D.N. , Kramer , D.M. et al. An Evaluation of Residual Gas Fraction Measurement Techniques in a High Degree of Freedom Spark Ignition Engine SAE Int. J. Engines 1 1 2008 71 84 https://doi.org/10.4271/2008-01-0094
  11. Matsui , K. , Tanaka , T. , and Ohigashi , S. Measurement of Local Mixture Strength at Spark Gap of S. I. Engines SAE Technical Paper 790483 1979 https://doi.org/10.4271/790483
  12. Weiss , P. and Keck , J.C. Fast Sampling Valve Measurements of Hydrocarbons in the Cylinder of a CFR Engine SAE Technical Paper 810149 1981 https://doi.org/10.4271/810149
  13. Sandqvist , H. , Wallensten , J. , Enwald , K. , and Strömberg , S. Influence of Valve Overlap Strategies on Residual Gas Fraction and Combustion in a Spark-Ignition Engine at Idle SAE Technical Paper 972936 1997 https://doi.org/10.4271/972936
  14. Westin , F. , Grandin , B. , and Ångström , H.-E. The Influence of Residual Gases on Knock in Turbocharged SI-Engines SAE Technical Paper 2000-01-2840 2000 https://doi.org/10.4271/2000-01-2840
  15. Schwarz , F. and Spicher , U. Determination of Residual Gas Fraction in IC Engines SAE Technical Paper 2003-01-3148 2003 https://doi.org/10.4271/2003-01-3148
  16. Giansetti , P. and Higelin , P. Residual Gas Fraction Measurement and Estimation in Spark Ignition Engine SAE Technical Paper 2007-01-1900 2007 https://doi.org/10.4271/2007-01-1900
  17. Jannoun , A. , Tauzia , X. , Chesse , P. , and Maiboom , A. Experimental Investigation of an In-Cylinder Sampling Technique for the Evaluation of the Residual Gas Fraction SAE Technical Paper 2017-24-0042 2017 https://doi.org/10.4271/2017-24-0042
  18. Cheng , W.K. , Galliot , F. , and Collings , N. On the Time Delay in Continuous In-Cylinder Sampling from IC Engines SAE Technical Paper 890579 1989 https://doi.org/10.4271/890579
  19. Collings , N. A New Technique for Measuring HC Concentration in Real Time, in a Running Engine SAE Technical Paper 880517 1988 https://doi.org/10.4271/880517
  20. Collings , N. and Willey , J. Cyclically Resolved HC Emissions from a Spark Ignition Engine SAE Technical Paper 871691 1987 https://doi.org/10.4271/871691
  21. Galliot , F. , Cheng , W.K. , Cheng , C.-O. , Sztenderowicz , M. et al. In-Cylinder Measurements of Residual Gas Concentration in a Spark Ignition Engine SAE Technical Paper 900485 1990 https://doi.org/10.4271/900485
  22. Fox , J.W. , Cheng , W.K. , and Heywood , J.B. A Model for Predicting Residual Gas Fraction in Spark-Ignition Engines SAE Technical Paper 931025 1993 https://doi.org/10.4271/931025
  23. Cho , H. , Lee , K. , Lee , J. , Yoo , J. et al. Measurements and Modeling of Residual Gas Fraction in SI Engines SAE Technical Paper 2001-01-1910 2001 https://doi.org/10.4271/2001-01-1910
  24. Iizuka , M. , Kato , N. , Kasashima , K. , and Muto , H. Carbon Dioxide Measuring Technology in Engine Combustion Chambers SAE Technical Paper 2004-01-1340 2004 https://doi.org/10.4271/2004-01-1340
  25. Zhang , Y. , Zhao , H. , Peckham , M. , and Campbell , B. Direct In-Cylinder CO2 Measurements of Residual Gas in a GDI Engine for Model Validation and HCCI Combustion Development SAE Technical Paper 2013-01-1654 2013 https://doi.org/10.4271/2013-01-1654
  26. Peckham , M. , Hands , T. , Burrell , J. , Collings , N. et al. Real Time In-Cylinder and Exhaust NO Measurements in a Production SI Engine SAE Technical Paper 980400 1998 https://doi.org/10.4271/980400
  27. Ford , R. and Collings , N. Measurement of Residual Gas Fraction Using a Fast Response NO Sensor SAE Technical Paper 1999-01-0208 1999 https://doi.org/10.4271/1999-01-0208
  28. Welling , O. and Collings , N. UEGO Based Measurement of EGR Rate and Residual Gas Fraction SAE Technical Paper 2011-01-1289 2011 https://doi.org/10.4271/2011-01-1289
  29. Copeland , C.D. , Gao , X. , Freeland , P.A. , Neumeister , J. et al. Simulation of Exhaust Gas Residuals in a Turbocharged, Spark Ignition Engine SAE Technical Paper 2013-01-2705 2013 https://doi.org/10.4271/2013-01-2705
  30. Silva , T.R.V. , Baeta , J.G.C. , Neto , N.A.D. , Malaquias , A.C.T. et al. Effects of Internal EGR on the Downsized Ethanol SIDI Engine Performance and Emission SAE Technical Paper 2017-36-0264 2017 https://doi.org/10.4271/2017-36-0264
  31. Lanzanova , T.D.M. , Nora , M.D. , Martins , M.E.S. , Machado , P.R.M. et al. The Effects of Residual Gas Trapping on Part Load Performance and Emissions of a Spark Ignition Direct Injection Engine Fuelled with Wet Ethanol Applied Energy 253 2019 1 14 https://doi.org/10.1016/j.apenergy.2019.113508
  32. Nguyen , D.-K. , Stepman , B. , Vergote , V. , Sileghem , L. et al. Combustion Characterization of Methanol in a Lean Burn Direct Injection Spark Ignition (DISI) Engine SAE Technical Paper 2019-01-0566 2019 https://doi.org/10.4271/2019-01-0566
  33. Nguyen , D.-K. , Craeynest , T.V. , Pillu , T. , Coulier , J. et al. Downsizing Potential of Methanol Fueled DISI Engine with Variable Valve Timing and Boost Control SAE Technical Paper 2018-01-0918 2018 https://doi.org/10.4271/2018-01-0918
  34. Wang , Y. , Conway , G. , and Chadwell , C. Combined Benefits of Variable Valve Actuation and Low-Pressure EGR on SI Engine Efficiency Part 1: Part Load SAE Technical Paper 2019-01-0241 2019 https://doi.org/10.4271/2019-01-0241
  35. Wang , Y. , Conway , G. , and Chadwell , C. Combined Benefits of Variable Valve Actuation and Low-Pressure EGR on SI Engine Efficiency Part 2: High Load SAE Technical Paper 2019-01-0237 2019 https://doi.org/10.4271/2019-01-0237
  36. Shayler , P.J. , Winborn , L.D. , Hill , M.J. , and Eade , D. The Influence of Gas/Fuel Ratio on Combustion Stability and Misfire Limits of Spark Ignition Engines SAE Technical Paper 2000-01-1208 2000 https://doi.org/10.4271/2000-01-1208
  37. Lavoie , G.A. , Martz , J. , Wooldridge , M. , and Assanis , D. A Multi-Mode Combustion Diagram for Spark Assisted Compression Ignition Combustion and Flame 157 6 2010 1106 1110 https://doi.org/10.1016/j.combustflame.2010.02.009
  38. Sjöberg , M. and Zeng , W. Combined Effects of Fuel and Dilution Type on Efficiency Gains of Lean Well-Mixed DISI Engine Operation with Enhanced Ignition and Intake Heating for Enabling Mixed-Mode Combustion SAE Int. J. Engines 9 2 2016 750 767 https://doi.org/10.4271/2016-01-0689
  39. Clasén , K. and Koopmans , L. Investigation of Homogeneous Lean SI Combustion in High Load Operating Conditions SAE Int. J. Adv. & Curr. Prac. in Mobility 2 4 2020 2051 2066 https://doi.org/10.4271/2020-01-0959
  40. Clasén , K. , Koopmans , L. , and Dahl , D. Homogeneous Lean Combustion in a 2lt Gasoline Direct Injected Engine with an Enhanced Turbo Charging System SAE Technical Paper 2018-01-1670 2018 https://doi.org/10.4271/2018-01-1670
  41. Pedrozo , V.B. , May , I. , Lanzanova , T.D.M. , and Zhao , H. Potential of Internal EGR and Throttled Operation for Low Load Extension of Ethanol-Diesel Dual-Fuel Reactivity Controlled Compression Ignition Combustion on a Heavy-Duty Engine Fuel 179 2016 391 405 https://doi.org/10.1016/j.fuel.2016.03.090
  42. Middleton , R.J. , Martz , J.B. , Lavoie , G.A. , Babajimopoulos , A. et al. A Computational Study and Correlation of Premixed Isooctane Air Laminar Reaction Fronts Diluted with EGR Combustion and Flame 159 2012 3146 3157 https://doi.org/10.1016/j.combustflame.2012.04.014
  43. Hanabusa , H. , Kondo , T. , Hashimoto , K. , Sono , H. et al. Study on Homogeneous Lean Charge Spark Ignition Combustion SAE Technical Paper 2013-01-2562 2013 https://doi.org/10.4271/2013-01-2562
  44. Sjöberg , M. , Zeng , W. , Singleton , D. , Sanders , J.M. et al. Combined Effects of Multi-Pulse Transient Plasma Ignition and Intake Heating on Lean Limits of Well-Mixed E85 DISI Engine Operation SAE Int. J. Engines 7 4 2014 1781 1801 https://doi.org/10.4271/2014-01-2615
  45. Doornbos , G. , Hemdal , S. , Denbratt , I. , and Dahl , D. Knock Phenomena under Very Lean Conditions in Gasoline Powered SI-Engines SAE Int. J. Engines 11 1 2018 1 16 https://doi.org/10.4271/03-11-01-0003
  46. Alriksson , M. , Rente , T. , and Denbratt , I. Low Soot, Low NOx in a Heavy Duty Diesel Engine Using High Levels of EGR SAE Technical Paper 2005-01-3836 2005 https://doi.org/10.4271/2005-01-3836
  47. Yan , B. , Yao , M. , Mao , B. , Li , Y. et al. A Comparative Study on the Fuel Economy Improvement of a Natural Gas SI Engine at the Lean Burn and the Stoichiometric Operation both with EGR under the Premise of Meeting EU6 Emission Legislation SAE Technical Paper 2015-01-1958 2015 https://doi.org/10.4271/2015-01-1958
  48. Lavoie , G.A. , Ortiz-Soto , E. , Babajimopoulos , A. , Martz , J.B. et al. Thermodynamic Sweet Spot for High-Efficiency, Dilute, Boosted Gasoline Engines Int. J. Engine Research 14 3 2012 260 278 https://doi.org/10.1177/1468087412455372
  49. Berntsson , A.W. , Josefsson , G. , Ekdahl , R. , Ogink , R. et al. The Effect of Tumble Flow on Efficiency for a Direct Injected Turbocharged Downsized Gasoline Engine SAE Int. J. Engines 4 2 2011 2298 2311 https://doi.org/10.4271/2011-24-0054
  50. Clasén , K. , Melaika , M. , Koopmans , L. , and Dahlander , P. High Load Lean SI-Combustion Analysis of DI Methane and Gasoline Using Optical Diagnostics with Endoscope SAE Technical Paper 2021-24-0046 2021 https://doi.org/10.4271/2021-24-0046
  51. Kolodziej , C.P. , Pamminger , M. , Sevik , J. , Wallner , T. et al. Effects of Fuel Laminar Flame Speed Compared to Engine Tumble Ratio, Ignition Energy, and Injection Strategy on Lean and EGR Dilute Spark Ignition Combustion SAE Int. J. Fuels Lubr. 10 1 2017 82 94 https://doi.org/10.4271/2017-01-0671
  52. Yoshihara , Y. , Nakata , K. , Takahashi , D. , Omura , T. et al. Development of High Tumble Intake-Port for High Thermal Efficiency Engines SAE Technical Paper 2016-01-0692 2016 https://doi.org/10.4271/2016-01-0692
  53. Wang , Y. , Zhang , J. , Yang , Z. , Wang , X. et al. Investigation of Flow Conditions and Tumble near the Spark Plug in a DI Optical Engine at Ignition SAE Technical Paper 2018-01-0208 2018 https://doi.org/10.4271/2018-01-0208
  54. Krüger , C. , Schorr , J. , Nicollet , F. , Bode , J. et al. Cause-and-Effect Chain from Flow and Spray to Heat Release during Lean Gasoline Combustion Operation Using Conditional Statistics Int. J. Engine Research 18 1-2 2017 143 154 https://doi.org/10.1177/1468087416686721
  55. Malaquias , A.C.T. , Netto , N.A.D. , Costa , R.B.R.d. , and Baêta , J.G.C. Combined Effects of Internal Exhaust Gas Recirculation and Tumble Motion Generation in a Flex-Fuel Direct Injection Engine Energy Conversion and Management 217 15-16 2020 2387 2404 https://doi.org/10.1016/j.enconman.2020.113007
  56. Sjöberg , M. and He , X. Combined Effects of Intake Flow and Spark-Plug Location on Flame Development, Combustion Stability and End-Gas Autoignition for Lean Spark-Ignition Engine Operation Using E30 Fuel Int. J. Engine Research 19 1 2018 86 95 https://doi.org/10.1177/1468087417740290
  57. Stenlåås , O. , Gogan , A. , Egnell , R. , Sundén , B. et al. The Influence of Nitric Oxide on the Occurrence of Autoignition in the End Gas of Spark Ignition Engines SAE Technical Paper 2002-01-2699 2002 https://doi.org/10.4271/2002-01-2699
  58. Roberts , P.J. and Sheppard , C.G.W. The Influence of Residual Gas NO Content on Knock Onset of Iso-Octane, PRF, TRF and ULG Mixtures in SI Engines SAE Int. J. Engines 6 4 2013 2028 2043 https://doi.org/10.4271/2013-01-9046

Cited By