Try Mobilus Beta
Search tips
 This content is not included in your SAE MOBILUS subscription, or you are not logged in.

Homogeneous Charge with Direct Injection Strategy to Achieve High Efficiency and Clean Combustion in Diesel Engines

Journal Article
03-14-03-0019
ISSN: 1946-3936, e-ISSN: 1946-3944
DOI: https://doi.org/10.4271/03-14-03-0019
Published February 12, 2021 by SAE International in United States
Homogeneous Charge with Direct Injection Strategy to Achieve High Efficiency and Clean Combustion in Diesel Engines
Sector:
Citation: Pandian, M. and Krishnasamy, A., "Homogeneous Charge with Direct Injection Strategy to Achieve High Efficiency and Clean Combustion in Diesel Engines," SAE Int. J. Engines 14(3):319-334, 2021, https://doi.org/10.4271/03-14-03-0019.
Language: English

References

  1. Heisler , H. Advanced Vehicle Technology Amsterdam Elsevier 2002
  2. Beatrice , C. , Di Blasio , G. , and Belgiorno , G. Experimental Analysis of Functional Requirements to Exceed the 100 kW/l in High-Speed Light-Duty Diesel Engines Fuel 207 591 601 2017
  3. Di Blasio , G. , Vassallo , A. , Pesce , F.C. , Beatrice , C. et al. The Key Role of Advanced, Flexible Fuel Injection Systems to Match the Future CO 2 Targets in an Ultra-Light Mid-Size Diesel Engine SAE Int. J. Engines 12 2 129 145 2019 https://doi.org/10.4271/2018-37-0005
  4. Dimitrakopoulos , N. , Belgiorno , G. , Tunér , M. , Tunestål , P. et al. Effect of EGR Routing on Efficiency and Emissions of a PPC Engine Applied Thermal Engineering 152 742 750 2019
  5. Belgiorno , G. , Dimitrakopoulos , N. , Di Blasio , G. , Beatrice , C. et al. Effect of the Engine Calibration Parameters on Gasoline Partially Premixed Combustion Performance and Emissions Compared to Conventional Diesel Combustion in a Light-Duty Euro 6 Engine Applied Energy 228 2221 2234 2018
  6. Di Blasio , G. , Bonura , G. , Frusteri , F. , Beatrice , C. et al. Experimental Characterization of Diesel Combustion Using Glycerol Derived Ethers Mixtures SAE Int. J. Fuels Lubr. 6 3 940 950 2013 https://doi.org/10.4271/2013-24-0104
  7. Di Blasio , G. , Belgiorno , G. , Beatrice , C. , Fraioli , V. et al. Experimental Evaluation of Compression Ratio Influence on the Performance of a Dual-Fuel Methane-Diesel Light-Duty Engine SAE Int. J. Engines 8 5 2253 2267 2015 https://doi.org/10.4271/2015-24-2460
  8. Johnson , T.V. Review of Diesel Emissions and Control International Journal of Engine Research 10 5 275 285 2009
  9. Chen , B. , Abeles , E. , Burke , A. , and Sperling , D. Effect of Emissions Regulation on Vehicle Attributes, Cost, and Price Contract 2 310 2004
  10. Reitz , R.D. and Duraisamy , G. Review of High Efficiency and Clean Reactivity-Controlled Compression Ignition (RCCI) Combustion in Internal Combustion Engines Progress in Energy and Combustion Science 46 12 71 2015
  11. Zhang , Y. , Ghandhi , J. , and Rothamer , D. Comparisons of Particle Size Distribution from Conventional and Advanced Compression Ignition Combustion Strategies International Journal of Engine Research 19 7 699 717 2018
  12. Pandian , M. and Krishnasamy , A. A Comparison of Different Low Temperature Combustion Strategies in a Small Single Cylinder diesel Engine under Low Load Conditions SAE Technical Paper 2017-01-2363 2017 https://doi.org/10.4271/2017-01-2363
  13. Milovanovic , N. , Chen , R. , Dowden , R. , and Turner , J. An Investigation of Using Various Diesel-Type Fuels in Homogeneous Charge Compression Ignition Engines and Their Effects on Operational and Controlling Issues International Journal of Engine Research 5 4 297 316 2004
  14. Shahbakhti , M. and Koch , C.R. Characterizing the Cyclic Variability of Ignition Timing in a Homogeneous Charge Compression Ignition Engine Fuelled with n-Heptane/Iso-Octane Blend Fuels International Journal of Engine Research 9 5 361 397 2008
  15. Jung , D. and Iida , N. Closed-Loop Control of HCCI Combustion for DME Using External EGR and Rebreathed EGR to Reduce Pressure-Rise Rate with Combustion-Phasing Retard Applied Energy 138 315 330 2015
  16. Maurya , R.K. Combustion Control Variables and Strategies Characteristics and Control of Low Temperature Combustion Engines Cham Springer 197 227 2018
  17. Johansson , T. , Johansson , B. , Tunestål , P. , and Aulin , H. 2010
  18. Olesky , L.M. , Martz , J.B. , Lavoie , G.A. , Vavra , J. et al. The Effects of Spark Timing, Unburned Gas Temperature, and Negative Valve Overlap on the Rates of Stoichiometric Spark Assisted Compression Ignition Combustion Applied Energy 105 407 417 2013
  19. Lavoie , G.A. , Martz , J. , Wooldridge , M. , and Assanis , D. A Multi-Mode Combustion Diagram for Spark Assisted Compression Ignition Combustion and Flame 157 6 1106 1110 2010
  20. Christensen , M. , Hultqvist , A. , and Johansson , B. Demonstrating the Multi Fuel Capability of a Homogeneous Charge Compression Ignition Engine with Variable Compression Ratio SAE Technical Paper 1999-01-3679 1999 https://doi.org/10.4271/1999-01-3679
  21. Pandian , M. and Krishnasamy , A. Effects of Compression Ratio and Water Vapor Induction on the Achievable Load Limits of a Light Duty Diesel Engine Operated in HCCI Mode SAE Technical Paper 2019-01-0962 2019 https://doi.org/10.4271/2019-01-0962
  22. Fathi , M. , Saray , R.K. , and Checkel , M.D. The Influence of Exhaust Gas Recirculation (EGR) on Combustion and Emissions of n-Heptane/Natural Gas Fueled Homogeneous Charge Compression Ignition (HCCI) Engines Applied Energy 88 12 4719 4724 2011
  23. Cairns , A. , Blaxill , H. , and Irlam , G. Exhaust Gas Recirculation for Improved Part and Full Load Fuel Economy in a Turbocharged Gasoline Engine SAE Technical Paper 2006-01-0047 2006 https://doi.org/10.4271/2006-01-0047
  24. Hyvonen , J. , Haraldsson , G. , and Johansson , B. Supercharging HCCI to Extend the Operating Range in a Multi-Cylinder VCR-HCCI Engine SAE Technical Paper 2003-01-3214 2003 https://doi.org/10.4271/2003-01-3214
  25. Christensen , M. and Johansson , B. Supercharged Homogeneous Charge Compression Ignition (HCCI) with Exhaust Gas Recirculation and Pilot Fuel SAE Technical Paper 2000-01-1835 2000 https://doi.org/10.4271/2000-01-1835
  26. Valero-Marco , J. , Lehrheuer , B. , Lopez , J.J. , and Pischinger , S. Potential of Water Direct Injection in a CAI/HCCI Gasoline Engine to Extend the Operating Range towards Higher Loads Fuel 231 317 327 2018
  27. Tanaka , S. , Ayala , F. , Keck , J.C. , and Heywood , J.B. Two-Stage Ignition in HCCI Combustion and HCCI Control by Fuels and Additives Combustion and Flame 132 1-2 219 239 2003
  28. An , Y. , Jaasim , M. , Raman , V. , Perez , F.E. et al. Homogeneous Charge Compression Ignition (HCCI) and Partially Premixed Combustion (PPC) in Compression Ignition Engine with Low Octane Gasoline Energy 158 181 191 2018
  29. Cho , K. , Zhao , L. , Ameen , M. , Zhang , Y. et al. Understanding Fuel Stratification Effects on Partially Premixed Compression Ignition (PPCI) Combustion and Emissions Behaviors SAE Technical Paper 2019-01-1145 2019 https://doi.org/10.4271/2019-01-1145
  30. Yang , Y. , Dec , J. , Dronniou , N. , and Cannella , W. Boosted HCCI Combustion Using Low-Octane Gasoline with Fully Premixed and Partially Stratified Charges SAE Int. J. Engines 5 3 1075 1088 2012 https://doi.org/10.4271/2012-01-1120
  31. Du , J. , Sun , W. , Guo , L. , Xiao , S. et al. Experimental Study on Fuel Economies and Emissions of Direct-Injection Premixed Combustion Engine Fueled with Gasoline/Diesel Blends Energy Conversion and Management 100 300 309 2015
  32. Ibrahim , M.M. , Narasimhan , J.V. , and Ramesh , A. Comparison of the Predominantly Premixed Charge Compression Ignition and the Dual Fuel Modes of Operation with Biogas and Diesel as Fuels Energy 89 990 1000 2015
  33. Jia , M. , Li , Y. , Xie , M. , Wang , T. et al. The Potential of High-Load Extension by Using Late Intake Valve Closing for a Diesel Premixed Charge Compression Ignition (PCCI) Engine Energy Procedia 66 33 36 2015
  34. Nevin , R.M. , Sun , Y. , and Reitz , R.D. PCCI Investigation Using Variable Intake Valve Closing in a Heavy Duty Diesel Engine SAE Technical Paper 2007-01-0903 2007 https://doi.org/10.4271/2007-01-0903
  35. Laguitton , O. , Crua , C. , Cowell , T. , Heikal , M.R. et al. The Effect of Compression Ratio on Exhaust Emissions from a PCCI Diesel Engine Energy Conversion and Management 48 11 2918 2924 2007
  36. Inagaki , K. , Fuyuto , T. , Nishikawa , K. , Nakakita , K. et al. Combustion System with Premixture-Controlled Compression Ignition R&D Rev Toyota CRDL 41 3 35 46 2006
  37. Iwashiro , Y. , Tsurushima , T. , Nishijima , Y. , Asaumi , Y. et al. Fuel Consumption Improvement and Operation Range Expansion in HCCI by Direct Water Injection SAE Technical Paper 2002-01-0105 2002 https://doi.org/10.4271/2002-01-0105
  38. Nishijima , Y. , Asaumi , Y. , and Aoyagi , Y. Impingement Spray System with Direct Water Injection for Premixed Lean Diesel Combustion Control SAE Technical Paper 2002-01-0109 2002 https://doi.org/10.4271/2002-01-0109
  39. Hildingsson , L. , Kalghatgi , G. , Tait , N. , Johansson , B. et al. Fuel Octane Effects in the Partially Premixed Combustion Regime in Compression Ignition Engines SAE Technical Paper 2009-01-2648 2009 https://doi.org/10.4271/2009-01-2648
  40. Kokjohn , S. , Hanson , R. , Splitter , D. , Kaddatz , J. et al. Fuel Reactivity Controlled Compression Ignition (RCCI) Combustion in Light-and Heavy-Duty Engines SAE Int. J. Engines 4 1 360 374 2011 https://doi.org/10.4271/2017-24-0072
  41. Shibata , G. , Oyama , K. , Urushihara , T. , and Nakano , T. The Effect of Fuel Properties on Low and High Temperature Heat Release and Resulting Performance of an HCCI Engine SAE Technical Paper 2004-01-0553 2004 https://doi.org/10.4271/2004-01-0553
  42. Benajes , J. , Molina , S. , García , A. , and Monsalve-Serrano , J. Effects of Low Reactivity Fuel Characteristics and Blending Ratio on Low Load RCCI (Reactivity-Controlled Compression Ignition) Performance and Emissions in a Heavy-Duty Diesel Engine Energy 90 1261 1271 2015
  43. Splitter , D. , Hanson , R. , Kokjohn , S. , and Reitz , R.D. Reactivity Controlled Compression Ignition (RCCI) Heavy-Duty Engine Operation at Mid-and High-Loads with Conventional and Alternative Fuels SAE Technical Paper 2011-01-0363 2011 https://doi.org/10.4271/2011-01-0363
  44. Benajes , J. , Molina , S. , García , A. , and Monsalve-Serrano , J. Effects of Direct Injection Timing and Blending Ratio on RCCI Combustion with Different Low Reactivity Fuels Energy Conversion and Management 99 193 209 2015
  45. Splitter , D. , Hanson , R. , Kokjohn , S. , Wissink , M. et al. Injection Effects in Low Load RCCI Dual-Fuel Combustion SAE Technical Paper 2011-24-0047 2011 https://doi.org/10.4271/2011-24-0047
  46. Splitter , D. , Wissink , M. , Kokjohn , S. , and Reitz , R.D. Effect of Compression Ratio and Piston Geometry on RCCI Load Limits and Efficiency SAE Technical Paper 2012-01-0383 2012 https://doi.org/10.4271/2012-01-0383
  47. Gupta , S.K. and Anand , K. Experimental Investigations to Reduce Unburned Emissions in Reactivity-Controlled Compression Ignition through Fuel Modifications Applied Thermal Engineering 146 622 634 2019
  48. Pandian , M.M. and Anand , K. Experimental Optimization of Reactivity-Controlled Compression Ignition Combustion in a Light Duty Diesel Engine Applied Thermal Engineering 138 48 61 2018
  49. Benajes , J. , García , A. , Monsalve-Serrano , J. , and Boronat , V. Achieving Clean and Efficient Engine Operation Up to Full Load by Combining Optimized RCCI and Dual-Fuel Diesel-Gasoline Combustion Strategies Energy Conversion and Management 136 142 151 2017
  50. Dernotte , J. , Dec , J. , and Ji , C. Investigation of the Sources of Combustion Noise in HCCI Engines SAE Int. J. Engines 7 2 730 761 2014 https://doi.org/10.4271/2014-01-1272
  51. Yun , H. , Wermuth , N. , and Najt , P. Extending the High Load Operating Limit of a Naturally-Aspirated Gasoline HCCI Combustion Engine SAE Int. J. Engines 3 1 681 699 2010 https://doi.org/10.4271/2010-01-0847

Cited By