This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
The Effect of Lubricant Composition on Vehicle Exhaust Emissions
Annotation ability available
Sector:
Language:
English
Abstract
The effect of lubricant composition on vehicle exhaust emissions has been investigated. Emissions from two vehicles were measured when lubricated with four different crankcase lubricants. All emissions tests were performed with California Phase II gasoline over the FTP-75 cycle. The lubricants tested were a conventional mineral oil based lubricant, poly-alpha olefin (PAO) based lubricant, hydrocracked based lubricant and a Volvo first fill lubricant. The first three lubricants were designed to have similar high temperature viscosities whilst using the same additive package. This meant that there were some small differences in the low temperature viscosities. This resulted in the two mineral oil based lubricants being 10W-30 grades and the PAO and hydrocracked based lubricants being 5W-30 grades.
The two test vehicles used were both Volvo 850 vehicles, however one was a European specification vehicle and the other a Californian TLEV. The European vehicle was equipped with a five cylinder 2.0 litre engine. The TLEV was powered by a five cylinder 2.5 litre engine, and was fitted with a secondary air pump and small volume starter catalyst immediately upstream of the main catalyst. This additional hardware enabled the TLEV to achieve rapid catalyst light off. Each vehicle/lubricant combination was tested a minimum of four times.
Lubricant composition had no effect on the emissions of total hydrocarbons, non-methane hydrocarbon, non-methane organic gases, speciated hydrocarbons or carbon monoxide. NOx emissions from both vehicles were affected by lubricant composition, with the NOx emissions from the TLEV being more sensitive to compositional changes in the lubricant. The PAO and hydrocracked lubricants gave lower NOx emissions, by up to 29%, compared to the mineral oil based products. These reductions can be explained by small differences in the tailpipe mixture strengths.
Recommended Content
Authors
Topic
Citation
Bennett, P., Copp, D., Linna, J., and Målberg, H., "The Effect of Lubricant Composition on Vehicle Exhaust Emissions," SAE Technical Paper 972930, 1997, https://doi.org/10.4271/972930.Also In
References
- Boam, D J Finlay, I C Biddulph, T W Ma, T A Lee, R Richardson, S H Bloomfield, J Green, J A Wallace, S Woods, W A Brown, P “The Sources of Unburnt Hydrocarbon Emissions from Spark Ignition Engines During Cold Starts and Warm-up” Proc. Instn. Mech. Engrs 208 1 1994
- Kaiser, E W Siegl, W O Russ, S G “Fuel Composition Effects on Hydrocarbon Emissions from a Spark-Ignited Engine - Is Fuel Absorption in Oil Significant?” SAE Paper 952542 1995
- Linna, J-R Malberg, H Bennett, P J Palmer, P J Tian, T Cheng, W K “Contribution of Oil Layer Mechanism to the Hydrocarbon Emissions from Spark-Ignition Engines” SAE Paper 97FL-433
- Zemroch, P J Schimmerling, P Sado, G Gray, C T Burghardt, H-M “European Programme on Emissions, Fuels and Engine Technologies (EPEFE) - Statistical Design and Analysis Techniques” SAE Paper 961069 1996
- American Society for Testing and Materials “Standard Practice for Dealing with Outlying Observations” ASTM 1989 1989
- Koehl, W J Gorse, R A Knepper, J C Rapp, L A Benson, J D Hochhauser A M Leppard, W R Reuter, R M Burns, V R Painter L J Rutherford, J A “Effects of Gasoline Sulfur Level on Exhaust Mass and Speciated Emissions: The Question of Linearity - Auto/Oil Air Quality Improvement Program” SAE Paper 932727 1993
- EUROPIA/ACEA 1995
- Palmer, F Petit, A Jeffrey, J Seinbrink, R “European Programme on Emissions, Fuels and Engine Technologies (EPEFE) - Gasoline Sulphur Study” SAE Paper 961071 1996