This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Investigating Pre-Mixed Charge Compression Ignition Combustion in a High Compression Ratio Engine
Technical Paper
2018-01-0900
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Utilizing a higher compression ratio in a Compression Ignition (CI) engine grants an obvious advantage of improved thermal efficiency. However, the resulting combustion temperatures promote dissociation ensuing in increased nitrogen oxide (NOx) emissions. Unfortunately, due to the inherent properties of CI combustion, it is difficult to achieve simultaneous reduction of NOx and particulate matter (PM) through conventional combustion methods. Taking a different route though accomplishing Homogeneous Charge Compression Ignition (HCCI) in CI engines will largely eliminate NOx and PM; however, combustion can result in a significant increase in hydrocarbon (HC) and carbon monoxide (CO) emissions due to the low volatility of diesel fuel. Hence, this work attempts another avenue of Low Temperature Combustion (LTC) by employing Pre-mixed Charge Compression Ignition (PCI) combustion on a comparatively higher compression ratio (21.2) single cylinder CI engine. An injection timing sweep was conducted using a common rail injection system with a 6-hole nozzle injector. Exhaust emissions were monitored using a Fourier Transform Infrared Spectroscopy device and Smoke Meter to analyze the extent of the NOx-PM trade-off along with both HC and CO emissions. Finally, a fuel injection quantity sweep with the fuel injection timing fixed at 60° Before Top Dead Center (BTDC) and 100° BTDC was performed to determine the maximum amount of fuel that may be injected early in the compression stroke without a significant growth in the heat release due to combustion. As the power generated was comparatively lower at advanced fuel injection timings, thermodynamic calculations and a heat release program were utilized to comprehend the magnitude of combustion.
Recommended Content
Authors
Topic
Citation
Srivatsa, C., Mattson, J., and Depcik, C., "Investigating Pre-Mixed Charge Compression Ignition Combustion in a High Compression Ratio Engine," SAE Technical Paper 2018-01-0900, 2018, https://doi.org/10.4271/2018-01-0900.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 | ||
Unnamed Dataset 3 | ||
Unnamed Dataset 4 |
Also In
References
- Ryan , T. and Callahan , T. Homogeneous Charge Compression Ignition of Diesel Fuel SAE Technical Paper 961160 1996 10.4271/961160
- Gan , S. , Ng , H.K. , and Pang , K.M. Homogeneous Charge Compression Ignition (HCCI) Combustion: Implementation and Effects on Pollutants in Direct Injection Diesel Engines Applied Energy 88 3 559 567 2011 10.1016/j.apenergy.2010.09.005
- Suzuki , H. , Koike , N. , and Odaka , M. Combustion Control Method of Homogeneous Charge Diesel Engines SAE Technical Paper 980509 1998 10.4271/980509
- Ganesh , D. and Nagarajan , G. Homogeneous Charge Compression Ignition (HCCI) Combustion of Diesel Fuel with External Mixture Formation SAE Technical Paper 2009-01-0924 2009 10.4271/2009-01-0924
- Singh , A. and Agarwal , A. An Experimental Investigation of Combustion, Emissions and Performance of a Diesel Fuelled HCCI Engine SAE Technical Paper 2012-28-0005 2012 10.4271/2012-28-0005
- Tsurushima , T. , Kunishima , E. , Asaumi , Y. , Aoyagi , Y. et al. The Effect of Knock on Heat Loss in Homogeneous Charge Compression Ignition Engines SAE Technical Paper 2002-01-0108 2002 10.4271/2002-01-0108
- Christensen , M. , Hultqvist , A. , and Johansson , B. Demonstrating the Multi Fuel Capability of a Homogeneous Charge Compression Ignition Engine with Variable Compression Ratio SAE Technical Paper 1999-01-3679 1999 10.4271/1999-01-3679
- Iwabuchi , Y. , Kawai , K. , Shoji , T. , and Takeda , Y. Trial of New Concept Diesel Combustion System - Premixed Compression-Ignited Combustion SAE Technical Paper 1999-01-0185 1999 10.4271/1999-01-0185
- Han , X. , Wang , M. , and Zheng , M. An Enabling Study of Neat N-Butanol HCCI Combustion on a High Compression-Ratio Diesel Engine SAE Technical Paper 2015-01-0001 2015 10.4271/2015-01-0001
- Dempsey , A.B. , Walker , N.R. , Gingrich , E. , and Reitz , R.D. Comparison of Low Temperature Combustion Strategies for Advanced Compression Ignition Engines with a Focus on Controllability Combustion Science and Technology 186 2 210 241 2014 10.1080/00102202.2013.858137
- Molina , S. , Garcia , A. , Pastor , J.M. , Belarte , E. et al. Operating Range Extension of RCCI Combustion Concept from Low to Full Load in a Heavy-Duty Engine Applied Energy 143 211 227 2015 10.1016/j.apenergy.2015.01.035
- Mattson , J. , Langness , C. , and Depcik , C. Exergy Analysis of Dual-Fuel Operation with Diesel and Moderate Amounts of Compressed Natural Gas in a Single-Cylinder Engine Combustion Science and Technology 190 3 471 489 2017 10.1080/00102202.2017.1399882
- Lee , J. , Goto , S. , Tsurushima , T. , Miyamoto , T. et al. Effects of Injection Conditions on Mixture Formation Process in a Premixed Compression Ignition Engine SAE Technical Paper 2000-01-1831 2000 10.4271/2000-01-1831
- Harada , A. , Shimazaki , N. , Sasaki , S. , Miyamoto , T. et al. The Effects of Mixture Formation on Premixed Lean Diesel Combustion Engine SAE Technical Paper 980533 1998 10.4271/980533
- Miyamoto , T. , Harada , A. , Sasaki , S. , Akagawa , H. et al. A Computational Investigation of Premixed Lean Diesel Combustion - Characteristics of Fuel-Air Mixture Formation, Combustion and Emissions SAE Technical Paper 1999-01-0229 1999 10.4271/1999-01-0229
- Nishijima , Y. , Asaumi , Y. , and Aoyagi , Y. Premixed Lean Diesel Combustion (PREDIC) Using Impingement Spray System SAE Technical Paper 2001-01-1892 2001 10.4271/2001-01-1892
- Akagawa , H. , Miyamoto , T. , Harada , A. , Sasaki , S. et al. Approaches to Solve Problems of the Premixed Lean Diesel Combustion SAE Technical Paper 1999-01-0183 1999 10.4271/1999-01-0183
- Odaka , M. , Suzuki , H. , Koike , N. , and Ishii , H. Search for Optimizing Control Method of Homogeneous Charge Diesel Combustion SAE Technical Paper 1999-01-0184 1999 10.4271/1999-01-0184
- Shimazaki , N. , Akagawa , H. , and Tsujimura , K. An Experimental Study of Premixed Lean Diesel Combustion SAE Technical Paper 1999-01-0181 1999 10.4271/1999-01-0181
- Ogawa , H. , Kimura , S. , Koike , M. , and Enomoto , Y. A Study of Heat Rejection and Combustion Characteristics of a Low-Temperature and Pre-Mixed Combustion Concept Based on Measurement of Instantaneous Heat Flux in a Direct-Injection Diesel Engine SAE Technical Paper 2000-01-2792 2000 10.4271/2000-01-2792
- Kimura , S. , Aoki , O. , Kitahara , Y. , and Aiyoshizawa , E. Ultra-Clean Combustion Technology Combining a Low-Temperature and Premixed Combustion Concept for Meeting Future Emission Standards SAE Technical Paper 2001-01-0200 2001 10.4271/2001-01-0200
- Walter , B. and Gatellier , B. Development of the High Power NADI™ Concept Using Dual Mode Diesel Combustion to Achieve Zero NO x and Particulate Emissions SAE Technical Paper 2002-01-1744 2002 10.4271/2002-01-1744
- Kawano , D. , Suzuki , H. , Ishii , H. , Goto , Y. et al. Ignition and Combustion Control of Diesel HCCI SAE Technical Paper 2005-01-2132 2005 10.4271/2005-01-2132
- Nishijima , Y. , Asaumi , Y. , and Aoyagi , Y. Impingement Spray System with Direct Water Injection for Premixed Lean Diesel Combustion Control SAE Technical Paper 2002-01-0109 2002 10.4271/2002-01-0109
- Lee , S. and Reitz , R. Spray Targeting to Minimize Soot and CO Formation in Premixed Charge Compression Ignition (PCCI) Combustion with a HSDI Diesel Engine SAE Technical Paper 2006-01-0918 2006 10.4271/2006-01-0918
- Jung , Y. , Bae , C. , Jang , J. , and Kim , D. Improvement of Premixed Compression Ignition Combustion Using Various Injector Configurations SAE Technical Paper 2011-01-1357 2011 10.4271/2011-01-1357
- Chen , Z. and Iwashina , T. HC and CO Formation Factors in a PCI Engine SAE Technical Paper 2009-01-1889 2009 10.4271/2009-01-1889
- Heywood , J.B. Internal Combustion Engine Fundamentals New York McGraw-Hill 1988
- Mangus , M.D. Implementation of Engine Control and Measurement Strategies for Biofuel Research in Compression-Ignition Engines Lawrence, KS Doctor of Philosophy, Department of Mechanical Engineering, University of Kansas 2014
- Langness , C. , Mangus , M. , and Depcik , C. Construction, Instrumentation, and Implementation of a Low Cost, Single-Cylinder Compression Ignition Engine Test Cell SAE Technical Paper 2014-01-0817 2014 10.4271/2014-01-0817
- Mangus , M. , Kiani , F. , Mattson , J. , Tabakh , D. et al. Investigating the Compression Ignition Combustion of Multiple Biodiesel/ULSD (Ultra-Low Sulfur Diesel) Blends Via Common-Rail Injection Energy 89 932 945 2015 10.1016/j.energy.2015.06.040
- Mattson , J. and Depcik , C. First and Second Law Heat Release Analysis in a Single Cylinder Engine SAE Int. J. Engines 9 1 544 553 2016 10.4271/2016-01-0559
- Mattson , J.M.S. Power, Efficiency, and Emissions Optimization of a Single Cylinder Direct-Injected Diesel Engine for Testing of Alternative Fuels through Heat Release Modeling Lawrence, KS Master of Science, Department of Mechanical Engineering, University of Kansas 2013
- Mattson , J. , Mangus , M. , and Depcik , C. Efficiency and Emissions Mapping for a Single-Cylinder, Direct Injected Compression Ignition Engine SAE Technical Paper 2014-01-1242 2014 10.4271/2014-01-1242
- Laguitton , O. , Crua , C. , Cowell , T. , Heikal , M.R. et al. The Effect of Compression Ratio on Exhaust Emissions from a PCCI Diesel Engine Energy Conversion and Management 48 11 2918 2924 2007 10.1016/j.enconman.2007.07.016
- Dickey , D. , Ryan , T. , and Matheaus , A. NO x Control in Heavy-Duty Diesel Engines - What Is the Limit? SAE Technical Paper 980174 1998 10.4271/980174
- Zádor , J. , Taatjes , C.A. , and Fernandes , R.X. Kinetics of Elementary Reactions in Low-Temperature Autoignition Chemistry Progress in Energy and Combustion Science 37 4 371 421 2011 10.1016/j.pecs.2010.06.006
- Griffiths , J. Why Cool Flames Are a Hot Prospect New Scientist 182 2450 28 29 2004
- Xu , G. , Ikegami , M. , Honma , S. , Ikeda , K. et al. Inverse Influence of Initial Diameter on Droplet Burning Rate in Cold and Hot Ambiences: A Thermal Action of Flame in Balance with Heat Loss International Journal of Heat and Mass Transfer 46 7 1155 1169 2003 10.1016/S0017-9310(02)00397-6
- Battin-Leclerc , F. Detailed Chemical Kinetic Models for the Low-Temperature Combustion of Hydrocarbons with Application to Gasoline and Diesel Fuel Surrogates Progress in Energy and Combustion Science 34 4 440 498 2008 10.1016/j.pecs.2007.10.002
- Titova , N. , Torokhov , S. , and Starik , A. On Kinetic Mechanisms of N-Decane Oxidation Combustion, Explosion, and Shock Waves 47 2 129 146 2011 10.1134/S0010508211020018
- Westbrook , C.K. and Dryer , F.L. Chemical Kinetic Modeling of Hydrocarbon Combustion Progress in Energy and Combustion Science 10 1 1 57 1984 10.1016/0360-1285(84)90118-7
- Glassman , I. , Yetter , R.A. , and Glumac , N.G. 2014
- Prikhodko , V. , Curran , S. , Barone , T. , Lewis , S. et al. Emission Characteristics of a Diesel Engine Operating with In-Cylinder Gasoline and Diesel Fuel Blending SAE Int. J. Fuels Lubr. 3 2 946 955 2010 10.4271/2010-01-2266
- Sharp , C. , Howell , S. , and Jobe , J. The Effect of Biodiesel Fuels on Transient Emissions from Modern Diesel Engines, Part II Unregulated Emissions and Chemical Characterization SAE Technical Paper 2000-01-1968 2000 10.4271/2000-01-1968
- Storey , J. , Lewis , S. , Parks , J. , Szybist , J. et al. Mobile Source Air Toxics (MSATs) from High Efficiency Clean Combustion: Catalytic Exhaust Treatment Effects SAE Int. J. Engines 1 1 1157 1166 2009 10.4271/2008-01-2431
- Kosaka , H. , Drewes , V. , Catalfamo , L. , Aradi , A. et al. Two-Dimensional Imaging of Formaldehyde Formed During the Ignition Process of a Diesel Fuel Spray SAE Technical Paper 2000-01-0236 2000 10.4271/2000-01-0236
- Schießl , R. , Dreizler , A. , Maas , U. , Grant , A. et al. Double-Pulse PLIF Imaging of Self-Ignition Centers in an SI Engine SAE Technical Paper 2001-01-1925 2001 10.4271/2001-01-1925
- Graf , N. , Gronki , J. , Schulz , C. , Baritaud , T. et al. In-Cylinder Combustion Visualization in an Auto-Igniting Gasoline Engine Using Fuel Tracer- and Formaldehyde-LIF Imaging SAE Technical Paper 2001-01-1924 2001 10.4271/2001-01-1924
- Chiang , C. , and Stefanopoulou , A. Sensitivity Analysis of Combustion Timing and Duration of Homogeneous Charge Compression Ignition (HCCI) Engines American Control Conference Minneapolis, MN 2006 10.1109/ACC.2006.1656490
- Choi , Y. and Chen , J.-Y. Fast Prediction of Start-Of-Combustion in HCCI with Combined Artificial Neural Networks and Ignition Delay Model Proceedings of the Combustion Institute 30 2 2711 2718 2005 10.1016/j.proci.2004.08.143
- Inhelder , J. , Frouzakis , C. , and Boulouchos , K. A Discussion of Approaches for Predicting End-Gas Autoignition in Homogeneous Charge Engines LVV Internal Report 93/20, ETHZ 1993
- Livengood , J. , and Wu , P. Correlation of Autoignition Phenomena in Internal Combustion Engines and Rapid Compression Machines Presented at Symposium (International) on Combustion. Elsevier 1955 10.1016/S0082-0784(55)80047-1 5 347 356
- Tanner , F. Liquid Jet Atomization and Droplet Breakup Modeling of Non-Evaporating Diesel Fuel Sprays SAE Technical Paper 970050 1997 10.4271/970050
- Weisser , G. , Tanner , F. , and Boulouchos , K. Modeling of Ignition and Early Flame Development with Respect to Large Diesel Engine Simulation SAE Technical Paper 981451 1998 10.4271/981451
- Assanis , D.N. , Filipi , Z.S. , Fiveland , S.B. , and Syrimis , M. A Predictive Ignition Delay Correlation Under Steady-State and Transient Operation of a Direct Injection Diesel Engine ASME Journal of Engineering for Gas Turbines and Power 125 2 450 457 2003 10.1115/1.1563238
- Hariyanto , A. , Bagiasna , K. , Asharimurti , I. , Wijaya , A. et al. Application of Wavelet Analysis to Determine the Start of Combustion of Diesel Engines SAE Technical Paper 2007-01-3556 2007 10.4271/2007-01-3556
- Stone , R. Introduction to Internal Combustion Engines Warrendale SAE International 1999