This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
The Effects of Injection Timing and Duration on Jet Penetration and Mixing in Multiple-Injection Schedules
Technical Paper
2016-01-0856
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Advanced injection schedules involving multiple injections have been utilized for reducing the peak cylinder pressure, phasing heat release rate, and reducing emissions in diesel engines. The timing and duration of the injections determine the injection schedule efficacy at achieving these effects. The goal of this work is to develop tools to track multiple injections to develop a better understanding of interaction mechanisms between subsequent injections. Both timing and duration effects are captured by using three different dwell times and seven injection durations. Experimental gas jet studies are conducted using schlieren. The jet-tip penetration rate, S, results do not reveal significant differences in jet-tip penetration with variations in the first-injection duration and dwell between injections. However, it was found that the jet spreading angles between the first and second injections differed, with the first injection having a higher average angle during the quasi-steady portion of the injection. This is indicative of differences in jet mixing and entrainment between the first and second injection.
Recommended Content
Authors
Topic
Citation
Borz, M., Kim, Y., and O'Connor, J., "The Effects of Injection Timing and Duration on Jet Penetration and Mixing in Multiple-Injection Schedules," SAE Technical Paper 2016-01-0856, 2016, https://doi.org/10.4271/2016-01-0856.Also In
References
- EPA, United States 2014 Control of Air Pollution from Motor Vehicles: Tier 3 Motor Vehicle Emission and Fuel Standards Federal Register
- 2009 Regulation (EC) European Parliament
- Tanaka , Takehiro , Ando , Akihiro , and Ishizaka , Kazuyoshi 2002 Study on pilot injection of DI diesel engine using common-rail injection system JSAE review 23 3 297 302
- Zhang , L. A Study of Pilot Injection in a DI Diesel Engine SAE Technical Paper 1999-01-3493 1999 10.4271/1999-01-3493
- Busch , S. , Zha , K. , Miles , P. , Warey , A. et al. Experimental and Numerical Investigations of Close-Coupled Pilot Injections to Reduce Combustion Noise in a Small-Bore Diesel Engine SAE Int. J. Engines 8 2 660 678 2015 10.4271/2015-01-0796
- Zeng , Weilin , He , Xu , Jin , Senjia , Liu , Hai , Li , Xiangrong , and Liu , Fushui 2013 Analysis of the influence of pilot injection timing on diesel combustion in an optical engine by the two-color method ASME 2013 Internal Combustion Engine Division Fall Technical Conference
- Bakenhus , M. and Reitz , R. Two-Color Combustion Visualization of Single and Split Injections in a Single-Cylinder Heavy-Duty D.I. Diesel Engine Using an Endoscope-Based Imaging System SAE Technical Paper 1999-01-1112 1999 10.4271/1999-01-1112
- Bower , G. and Foster , D. The Effect of Split Injection on Fuel Distribution in an Engine-Fed Combustion Chamber SAE Technical Paper 930864 1993 10.4271/930864
- Han , Z. , Uludogan , A. , Hampson , G. , and Reitz , R. Mechanism of Soot and NOx Emission Reduction Using Multiple-injection in a Diesel Engine SAE Technical Paper 960633 1996 10.4271/960633
- Tow , T. , Pierpont , D. , and Reitz , R. Reducing Particulate and NOx Emissions by Using Multiple Injections in a Heavy Duty D.I. Diesel Engine SAE Technical Paper 940897 1994 10.4271/940897
- Nehmer , D. and Reitz , R. Measurement of the Effect of Injection Rate and Split Injections on Diesel Engine Soot and NOx Emissions SAE Technical Paper 940668 1994 10.4271/940668
- Ehleskog , R. , Golovitchev , V. , Denbratt , I. , Andersson , S. et al. Experimental and Numerical Investigation of Split Injections at Low Load in an HDDI Diesel Engine Equipped with a Piezo Injector SAE Technical Paper 2006-01-3433 2006 10.4271/2006-01-3433
- Herfatmanesh , Mohammad Reza , Lu , Pin , Attar , Mohammadreza Anbari , and Zhao , Hua 2013 Experimental investigation into the effects of two-stage injection on fuel injection quantity, combustion and emissions in a high-speed optical common rail diesel engine Fuel 109 137 147
- Skeen , S. , Manin , J. , and Pickett , L. Visualization of Ignition Processes in High-Pressure Sprays with Multiple Injections of n-Dodecane SAE Int. J. Engines 8 2 696 715 2015 10.4271/2015-01-0799
- 2015 Engine Combustion Network July 15 2015 http://www.sandia.gov/ecn/
- Goldwine , Gideon , and Sher , Eran 2009 Experimental investigation of the effect of split injection on diesel engine performance International Journal of Vehicle Design 50 1-4 66 90
- Herfatmanesh , Mohammad Reza , and Zhao , Hua 2012 Experimental investigation of effects of dwell angle on fuel injection and diesel combustion in a high-speed optical CR diesel engine Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering :0954407012450656
- O'Connor , J. and Musculus , M. Optical Investigation of the Reduction of Unburned Hydrocarbons Using Close-Coupled Post Injections at LTC Conditions in a Heavy-Duty Diesel Engine SAE Int. J. Engines 6 1 379 399 2013 10.4271/2013-01-0910
- O'Connor , Jacqueline , and Musculus , Mark 2014 Effect of Reduction in an Optical Heavy-Duty Diesel Research Engine Journal of Engineering for Gas Turbines and Power 136 10.1115/1.4027276
- O'Connor , J. and Musculus , M. In-Cylinder Mechanisms of Soot Reduction by Close-Coupled Post-Injections as Revealed by Imaging of Soot Luminosity and Planar Laser-Induced Soot Incandescence in a Heavy-Duty Diesel Engine SAE Int. J. Engines 7 2 673 693 2014 10.4271/2014-01-1255
- Hessel , R. , Reitz , R. , Musculus , M. , O'Connor , J. et al. A CFD Study of Post Injection Influences on Soot Formation and Oxidation under Diesel-Like Operating Conditions SAE Int. J. Engines 7 2 694 713 2014 10.4271/2014-01-1256
- Yun , Hanho , Sun , Yong , and Reitz , Rolf D. 2005 An experimental and numerical investigation on the effect of post injection strategies on combustion and emissions in the low-temperature diesel combustion regime ASME 2005 Internal Combustion Engine Division Spring Technical Conference
- Bobba , M. , Musculus , M. , and Neel , W. Effect of Post Injections on In-Cylinder and Exhaust Soot for Low-Temperature Combustion in a Heavy-Duty Diesel Engine SAE Int. J. Engines 3 1 496 516 2010 10.4271/2010-01-0612
- Chen , S. Simultaneous Reduction of NOx and Particulate Emissions by Using Multiple Injections in a Small Diesel Engine SAE Technical Paper 2000-01-3084 2000 10.4271/2000-01-3084
- Hotta , Y. , Inayoshi , M. , Nakakita , K. , Fujiwara , K. et al. Achieving Lower Exhaust Emissions and Better Performance in an HSDI Diesel Engine with Multiple Injection SAE Technical Paper 2005-01-0928 2005 10.4271/2005-01-0928
- Vanegas , A. , Won , H. , Felsch , C. , Gauding , M. et al. Experimental Investigation of the Effect of Multiple Injections on Pollutant Formation in a Common-Rail DI Diesel Engine SAE Technical Paper 2008-01-1191 2008 10.4271/2008-01-1191
- Parrish , S. , Zhang , G. , and Zink , R. Liquid and Vapor Envelopes of Sprays from a Multi-Hole Fuel Injector Operating under Closely-Spaced Double-Injection Conditions SAE Int. J. Engines 5 2 400 414 2012 10.4271/2012-01-0462
- Bruneaux , G. and Maligne , D. Study of the Mixing and Combustion Processes of Consecutive Short Double Diesel Injections SAE Int. J. Engines 2 1 1151 1169 2009 10.4271/2009-01-1352
- Skeen , Scott A , Manin , Julien , and Pickett , Lyle M. 2014 Advanced Diagnostics for High Pressure Spray Combustion. Sandia National Laboratories (SNL-CA) Livermore, CA (United States)
- Zha , K. , Busch , S. , Miles , P. , Wijeyakulasuriya , S. et al. Characterization of Flow Asymmetry During the Compression Stroke Using Swirl-Plane PIV in a Light-Duty Optical Diesel Engine with the Re-entrant Piston Bowl Geometry SAE Int. J. Engines 8 4 1837 1855 2015 10.4271/2015-01-1699
- Jung , Y. , Manin , J. , Skeen , S. , and Pickett , L. Measurement of Liquid and Vapor Penetration of Diesel Sprays with a Variation in Spreading Angle SAE Technical Paper 2015-01-0946 2015 10.4271/2015-01-0946
- Eagle , W. Ethan , Musculus , Mark P. B. , Malbec , L-M. C. , and Bruneaux , G. 2015 Measuring transient entrainment rates of a confined vaporizing diesel jet ILASS Americas 26th Annual Conference on Liquid Atomization and Spray Systems Portland, OR
- Naber , J. and Siebers , D. Effects of Gas Density and Vaporization on Penetration and Dispersion of Diesel Sprays SAE Technical Paper 960034 1996 10.4271/960034
- Abani , Neerav , and Ghandhi , Jaal B. 2012 Behavior of Unsteady Turbulent Starting Round Jets Journal of Fluids Engineering 134 6 061202
- Musculus , M. and Kattke , K. Entrainment Waves in Diesel Jets SAE Int. J. Engines 2 1 1170 1193 2009 10.4271/2009-01-1355
- Han , Donghee , and Mungal , MG 2001 Direct measurement of entrainment in reacting/nonreacting turbulent jets Combustion and flame 124 3 370 386
- Wakuri , Yutaro , Fujii , Masaru , Amitani , Tatsuo , and Tsuneya , Reijiro 1960 Studies on the penetration of fuel spray in a diesel engine Bulletin of JSME 3 9 123 130