This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Optimal Energy Management of Hybrid Fuel Cell Electric Vehicles
Technical Paper
2015-01-1359
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
An optimal energy management system is presented to minimize hydrogen utilization over driving cycles using forward dynamic programming (FDP). The objective is to minimize the cost of hydrogen with the battery cost being used as a parameter to carry out charge-depleting as well as charge-sustaining strategies along with bound enforcement or relaxation. The problem formulation accounts for the power balance at each stage, the power limits, the state-of-charge limits, and the ramp rates constraints of the fuel cell and battery. FDP is selected because it can easily cater for non-linearity in system cost and constraints. It employs heuristic rules to limit the number of states at each stage and is shown to be a very fast algorithm using simple computations and thus may easily lend itself for real-time implementation. Charge sustained operation is obtained by enforcement of the lower bound on the SOC, and charge depletion operation is obtained by lowering the bound to the required depletion level. In both cases a battery cost parameter is set to a value lower than the incremental cost of the fuel cell calculated at the average load of the car for the given drive cycle. Verification of the code is provided by comparing it to results obtained using quadratic programming. Results on practical vehicle designs proposed in the literature are presented for the UDDS and HWFET standard driving cycles.
Recommended Content
Authors
Topic
Citation
Karaki, S., Jabr, R., Chedid, R., and Panik, F., "Optimal Energy Management of Hybrid Fuel Cell Electric Vehicles," SAE Technical Paper 2015-01-1359, 2015, https://doi.org/10.4271/2015-01-1359.Also In
References
- Bernard J. , Delprat S. , Guerra T.M. , Buchi F.N. 2010 Fuel efficient power management strategy for fuel cell hybrid power-trains Control Engineering Practice 18 408 417
- Serrao L. , Sciarretta A. , Grondin O. , Chasse A. , Creff Y. , di Domenico Domenico , Pognant-Gros P. , Querel C. and Thibault L. 2011 Open Issues in Supervisory Control of Hybrid Electric Vehicles: A Unified Approach using Optimal Control Methods Int. Scientific Conf. on hybrid and electric vehicles RHEVE 2011 6 7 December 2011
- Xiong W. , Zhang Y. , Yin C. 2009 Optimal energy management for a series-parallel hybrid electric bus Energy Conversion and Management 50 1730 1738
- Erdinc O. , Vural B. , Uzunoglu M. 2009 A wavelet-fuzzy logic based energy management strategy for a fuel cell/battery/ultra-capacitor hybrid vehicular power system Journal of Power Sources 194 369 380
- Lin W. S. , Zheng C. H. 2011 Energy management of a fuel cell/ultra-capacitor hybrid power system using an adaptive optimal-control method Journal of Power Sources 196 3280 3289
- Schell A. , Peng H. , Tran D. , Stamos E. , Lin C. C. , Kim M. J. 2005 Modeling and control strategy development for fuel cell electric vehicles Annual Reviews in Control 29 159 168
- Perez L. V. , Pilotta E. A. 2009 Optimal power split in a hybrid electric vehicle using direct transcription of an optimal control problem Mathematics and Computers in Simulation 79 1959 70
- Wang R. and Lukic , S.M. 2012 Dynamic programming technique in hybrid electric vehicle optimization 2012 IEEE International Electric Vehicle Conference (IEVC) 10.1109/IEVC.2012.6183284 1 8
- Boyali , A. and Guvenc L. 2010 Real-time controller design for a parallel hybrid electric vehicle using neuro-dynamic programming method 2010 IEEE International Conference on Systems Man and Cybernetics (SMC) 4318 4324
- Johannesson L. , Pettersson S. , Egardt B. 2009 Predictive energy management of a 4QT series-parallel hybrid electric bus Control Engineering Practice 17 1440 1453
- Chasse A. , Sciarretta A. 2011 Supervisory control of hybrid power-trains: An experimental benchmark of offline optimization and on-line energy management Control Engineering Practice 19 1253 1265
- Kim , N. and Rousseau , A. Comparison between Rule-Based and Instantaneous Optimization for a Single-Mode, Power-Split HEV SAE Technical Paper 2011-01-0873 2011 10.4271/2011-01-0873
- Ambuhl D. , Sundstrom O. , Sciarretta A. , Guzzella L. 2010 Explicit optimal control policy and its practical application for hybrid electric power-trains Control Engineering Practice 18 1429 1439
- Sorrentino M. , Rizzo G. , Arsie I. 2011 Analysis of a rule-based control strategy for on-board energy management of series hybrid vehicles Control Engineering Practice 19 1433 1441
- Panik , F. , Huang , Y. , Boff , A. , Gonzalves , S. et al. Design and Simulation Models for a Brazilian Hybrid Delivery Truck SAE Technical Paper 2011-36-0162 2011 10.4271/2011-36-0162
- EPA 2013 Dynamometer Drive Schedules 2 6 2013 http://www.epa.gov/oms/emisslab/testing/dynamometer.htm
- Rizzoni G. , Guzzella L. , and Baumann B. M. 1999 United modeling of hybrid electric vehicle drive trains IEEE/ASME Transactions on Mechatronics 4 3 246 257
- Larminie J. and Dicks A. 2003 Fuel Cell Systems Explained 2nd John Wiley & Sons Ltd Chichester, England 47 60
- DOE 2012 Fuel Cell System Cost - 2012”, DOE Fuel Cell Technologies Program Record # 12020
- Saft 2007 Saft VL 6Ah Data Sheet Saft America Inc. Document No. 5406-2-0807 September 2007 www.saftbatteries.com
- Lasdon L. S. 1970 Optimization Theory for Large Systems New York McMillan
- Wood A. J. and Wollenberg B. F. Power Generation Operation and Control 2nd John Wiley and Sons New York 1996 142 147
- Karaki S. H. , Chaaban F. , Al-Nakhl N. , and Tarhini K. 2002 Power Generation Expansion Planning with an Environmental Assessment for Lebanon International Journal of Electrical Power & Energy Systems 24 8 611 619
- Park J. H. , Kim S. K. , Park G. P. , Yoon Yong-Tae , Lee S. S. 2010 Modified dynamic programming based unit commitment technique IEEE Power and Energy Society General Meeting 30 September 2010 978-1-4244-8357-0
- Jabr R. A. 2003 A primal-dual interior-point method to solve the optimal power flow dispatching problem Optimization and Engineering Kluwer Academic Publishers 4 309 336
- Bayard D. S. 1992 Reduced Complexity Dynamic Programming Based on Policy Iteration Journal of Mathematical Analysis and Applications 170 75 103 1992
- Elgowainy A. , Han J. , Poch L. , Wang M. , Vyas A. , Mahalik M. , and Rousseau A. 2010 Well-to-wheels Analysis of Energy Use and Greenhouse Gas Emissions of Hybrid Plug-In Electric Vehicles Energy Systems Division, Argonne National Laboratory