This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
PMP-based Fuel Cell Hybrid Vehicle Power Management Considering Battery Current Constraint and Battery Health Analysis
Technical Paper
2015-01-1217
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Many problems are associated with the large battery operation current, such as battery overheating, lithium plating, and mechanical structural instability of battery materials. All these problems may cause battery safety issues in fuel cell hybrid vehicles (FCHVs), e.g., battery explosions and thermal runaway have been reported and may cause public anxiety about FCHVs. Previous researches on FCHV power management strategy have focused on minimizing fuel consumption. But more attention needs to put on the battery current constraint for analysis of battery state of charge (SOC) and battery state of health (SOH). This research targets optimizing the FCHV battery pack operation within a safe current range through power management strategy to increase the safety of the battery pack while improving battery usage via SOC control. Battery SOH is also evaluated in the study. This paper presents a Pontryagin's minimum principle (PMP)-based FCHV power management with consideration of battery current constraint, SOC, and SOH. PMP is applied as the power management strategy to optimize splitting the power between battery pack and fuel cell stack at each time step during the operation. Battery current constraint is coupled as a cost function in PMP control with fuel consumption as another cost function. The results show that applying battery current constraint results in a smaller battery current range and two times less of the SOC drop slope. In addition, 0.02% of battery SOH improvement is obtained under one single FTP-72 driving cycle.
Recommended Content
Authors
Citation
Liu, C. and Liu, L., "PMP-based Fuel Cell Hybrid Vehicle Power Management Considering Battery Current Constraint and Battery Health Analysis," SAE Technical Paper 2015-01-1217, 2015, https://doi.org/10.4271/2015-01-1217.Also In
References
- Serrao Lorenzo , S.O. , Rizzoni Giorgio A Comparative Analysis of Energy Management Strategy Dynamic Systems, Measurement, and Control 133 2011
- Kim Namwook , S.C. , and Peng Huei Optimal Control of Hybrid Electric Vehicles Based on Pontryagin's Minimum Principle IEEE Transactions on control, systems techology 19 5 2011
- Xu , L.F. et al. Optimal Sizing of Plug-in Fuel Cell Electric Vehicles Using Models of Vehicle Performance and System Cost Applied Energy 103 0 2013 10.1016/j.apenergy.2012.10.010
- Zheng , C. et al. Pmp-Based Power Management Strategy of Fuel Cell Hybrid Vehicles Considering Multi-Objective Optimization International Journal of Precision Engineering and Manufacturing 14 5 2013
- Kim , M.-J. and Peng H. Power Management and Design Optimization of Fuel Cell/Battery Hybrid Vehicles Journal of Power Sources 165 2 2007 10.1016/j.jpowsour.2006.12.038
- Chan-Chiao , L. et al. Power Management Strategy for a Parallel Hybrid Electric Truck Control Systems Technology, IEEE Transactions 11 6 2003
- Zheng , C.H. et al. Power Source Sizing of Fuel Cell Hybrid Vehicles Considering Vehicle Performance and Cost International Journal of Precision Engineering and Manufacturing 15 3 2014 10.1007/s12541-014-0367-0
- Zheng , C.H. et al. Prolonging Fuel Cell Stack Lifetime Based on Pontryagin's Minimum Principle in Fuel Cell Hybrid Vehicles and Its Economic Influence Evaluation Journal of Power Sources 248 0 2014 10.1016/2013.09.110
- Balakrishnan , P.G. , Ramesh R. , and Kumar T. Prem Safety Mechanisms in Lithium-Ion Batteries Journal of Power Sources 155 2 2006
- Wang , Q. et al. Thermal Runaway Caused Fire and Explosion of Lithium Ion Battery Journal of power sources 208 2012
- Serrao , L. , Onori S. , and Rizzoni G. A Comparative Analysis of Energy Management Strategies for Hybrid Electric Vehicles Journal of Dynamic Systems Measurement and Control-Transactions of the Asme 133 3 2011 10.1115/1.4003267
- Musardo , C. et al. A-Ecms: An Adaptive Algorithm for Hybrid Electric Vehicle Energy Management European Journal of Control 11 4 2005
- Kim , N. , Cha S. , and Peng H. Optimal Control of Hybrid Electric Vehicles Based on Pontryagin's Minimum Principle IEEE Transactions on Control Systems Technology 19 5 2011 10.1109/Tcst.2010.2061232
- Changzhou HECO New Energy Technology Co., L. Rechargeable Lithium Batteries, Customize Size, 5ah - 20Ah LiFePO 4 BatteryCell http://www.hecobattery.com/china-rechargeable_lithium_batteries_customize_size_5ah_20ah_lifepo4_battery_cell-1303828.html 2014 October
- Rezvanizaniani , S.M. et al. Review and Recent Advances in Battery Health Monitoring and Prognostics Technologies for Electric Vehicle (Ev) Safety and Mobility Journal of Power Sources 256 0 2014
- Stephen Drouilhet, B.L.J. A Battery Life Prediction Method for Hybrid Power Applications AIAA, Aerospace Sciences Meeting & Exhibit,35th 1997
- Andre , D. et al. Advanced Mathematical Methods of Soc and Soh Estimation for Lithium-Ion Batteries Journal of power sources 224 2013
- Gould , C.R. et al. New Battery Model and State-of-Health Determination through Subspace Parameter Estimation and State-Observer Techniques Vehicular Technology, IEEE Transactions 58 8 2009
- Santhanagopalan , S. and White R.E. Online Estimation of the State of Charge of a Lithium Ion Cell Journal of power sources 161 2 2006
- Liu , D. et al. Prognostics for State of Health Estimation of Lithium-Ion Batteries Based on Combination Gaussian Process Functional Regression Microelectronics Reliability 53 6 2013
- Bhangu , B.S. et al. Nonlinear Observers for Predicting State-of-Charge and State-of-Health of Lead-Acid Batteries for Hybrid-Electric Vehicles Vehicular Technology, IEEE Transactions 54 3 2005
- US Battery Mfg. Co., D.C.P. Expected Average Life Cycles http://usbattery.com/ 2014 October