This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Performance, Emission and Combustion, Analysis of Diesel Engine Fueled with Blends of Mahua Oil Methyl Ester and Diesel
Technical Paper
2014-01-2651
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The rising cost and limited availability of crude oil in international market has provided an opportunity to look for substitute of fossil fuel. Scientists all over the world are experimenting on variety of renewable fuels for meeting the future energy demands. Bio origin fuels are fast becoming potential alternative resources to replace the fossil fuels. The vegetable oils, derived from oil seed crops have got 90 to 95% energy value of diesel on volume basis, comparable cetane number and can substitute upto 20% (v/v) of diesel fuel. Mahua seed oil is common ingredient of hydrogenated fat. Two-step transesterification process was employed to synthesize biodiesel from Mahua Oil (Madhuca-indica) and analysis of Physico-chemical properties as well as the combustion, performance and emission characteristics was done by taking 10, 20 and 100 % blend with diesel. The physico-chemical properties of the blends were found to be comparable to diesel. Engine performance like Brake Thermal Efficiency (BTE) decreased slightly for all the blends of mahua oil methyl ester. At full load condition CO emission was 38% lower while NOx was found to be 21 % higher than that of neat diesel. HC emission was 42 ppm for pure mahua biodiesel and 58 ppm for diesel fuel. Smoke opacity for all the blends of mahua oil methyl ester was lower than mineral diesel. Combustion result shows ignition lag for all the blends of mahua oil methyl ester. Ignition delay for D100 is found at 10.5° while for neat mahua oil methyl ester it is 7°. However for M10 and M20 ignition delay varied from 7.3°, and 8° respectively. On an overall analysis it can be concluded that upto 20 % (v/v) of diesel can be easily substituted by mahua oil biodiesel and can be run on an unmodified single cylinder diesel engine.
Authors
Topic
Citation
Vibhanshu, V., Karnwal, A., Deep, A., and Kumar, N., "Performance, Emission and Combustion, Analysis of Diesel Engine Fueled with Blends of Mahua Oil Methyl Ester and Diesel," SAE Technical Paper 2014-01-2651, 2014, https://doi.org/10.4271/2014-01-2651.Also In
References
- Puhan Sukumar , Vedaramana N. , Sankaranarayanana G. , Rama Boppana V. Bharat Performance and emission study of Mahua oil(madhucaindica oil) ethyl ester in a 4-strokenatural aspirated direct injection diesel engine Renewable Energy 30 2005 1269 1278
- Shahid Ejaz M. , Jamal Younis Production of biodiesel: A technical review Renewable and Sustainable Energy Reviews 15 2011 4732 4745
- Rösch C , Skarka J. The European biofuels policy and sustainability IntAssocEnergy Econ 2009 31 5
- BP Statistical Review of World Energy 2012
- Bioengineering Resource Inc. www.brienergy.com 12 08 2013
- US Energy Department www.energy.gov 12 08 2013
- Basic Statistics on Indian Petroleum & Natural Gas 2011 Ministry Of Petroleum & Natural Gas, Government Of India New Delhi (Economic Division)
- Pricing and Resource Allocation to Take Place Under Market Forces Under an Effective and Credible Regulatory Oversight, as Far as Possible, Integrated energy policy Govt. of India
- 12th five year plan Government of India
- http://www.mnre.gov.in/mission-and-vision-2/achievements/ 1 09 2013
- Al-Widyan MI , Al-Shyoukh AO. Experimental evaluation of the transesterificationof waste palm oil into biodiesel BioresourTechnol 2002 85 253 6
- Dunn RO. Alternative jet fuels from vegetable oils Trans ASAE 2001 44 1751 7
- Rao GLN , Sampath S , Rajagopal K. Experimental studies on the combustionand emission characteristics of a diesel engine fuelled with used cooking oilmethyl ester and its diesel blends Int J ApplSciEngTechnol 2008 4 64 70
- Sinha S , Agarwal AK , Garg S. Biodiesel development from rice bran oil: transesterificationprocessoptimization and fuel characterization Energy ConverManage 2008 49 5 1248 57
- Schumacher LG , Marshall WJ , Krahl WB , Wetherell MS , Grabowski MS. Biodiesel emissions data from Series 60 DDC engines Trans ASAE 2001 44 1465 8
- Utlu Z , Su M , Kocak R. The effect of biodiesel fuel obtained from waste frying oilon direct injection diesel engine performance and exhaust emissions Renewable Energy 2008 33 1936 41
- Sahoo PK , Das LM , Babu MKG , Naik SN. Biodiesel development from highacid value polanga seed oil and performance evaluation in a CI engine Fuel 2007 86 448 54
- Phan AN , Phan TM. Biodiesel production from waste cooking oils Fuel 2008 87 3490 6
- Yage D , Cheung CS , Huang Z. Experimental investigation on regulatedand unregulated emissions of a diesel engine fueled with ultra-low sulfurdiesel fuel blended with biodiesel from waste cooking oil Sci Total Environ 2009 40 835 46
- Fernando Bautista Luis , Gemma Vicente , Rodríguez Rosalı , Pacheco María Optimisation of FAMEproduction from waste cooking oil for biodiesel use biomassand bioenergy 33 2009 862 872
- Enweremadu C.C. , Rutto H.L. Combustion, emissionand engine performance characteristics of used cooking oilbiodiesel-A review Renewable and Sustainable EnergyReviews 14 2010 2863 2873
- Sukumar Puhan , Vedaraman N , Rambrahamam B V and Nagarajan G Mahua (Madhucaindica) seed oil: A sourceofrenewable energy in India Journal of Scientific &IndustrialResearch 64 November 2005 890 896
- Basha SA , Gopal KR , Jebaraj S. A review on biodiesel production, combustion, emissions and performance Renew Sustain Energy Rev 2009 13 1628 34
- Canoira L , Alcantara R , Garcia-Martinez MJ , Carrasco J. Biodiesel from Jojobaoilwax: transesterification with methanol and properties as a fuel BiomassBioenergy 2006 30 76 81
- Demirbas A. Biodiesel production via noncatalytic SCF method and biodieselfuel characteristics Energy Convers Manage 2006 47 2271 82
- Rakopoulos CD. Comparative performance and emission studies when usingolive oil as a fuel supplement in DI and IDI diesel engines Renew Energy 1992 2 327 31
- Keskin A , Gürü M , Altıparmak D , Aydın K. Using cotton oil biodiesel-dieselfuel blends as alternative diesel fuel Renew Energy 2008 33 553 7
- Patil B.S. , Gosai D.C. and patel A.J. Performance analysis of dual cylinder diesel engine fueled with mahuabiodiesel World Journal of Science and Technology 2012 2 4 24 27
- Production Of biodiesel from jatropha oil catalyzed by nanosized solid basic catalyst Energy 36 2 February 2011 777 784
- Xin Deng , Zhen Fang , Yun-hu Liu , Chang-Liu Yu Biodiesel production from Jatropha oil by catalytic and noncatalytic approaches Bioresource Technology 102 2 January 2011 452 460
- JoonChing Juan , Agung KartikaDamayani , Yeong Wu Ta , Yun Hin Taufiq-Yap Biodiesel Production from Crude Jatropha curcas L. Oil with Trace Acid Catalyst Chinese Journal of Chemical Engineering 20 4 August 2012 740 746
- Yingying LIU , Houfang LU , Wei JIANG , Dongsheng LI , Shijie LIU , Bin LIANG Preparation of biodiesel from Jatropha curcas L. oil produced by two-phase solvent extraction Bioresource Technology 101 18 September 2010 7025 7031
- Junfeng Qian , Haixian Shi , Zhi Yun Ultrasonic transesterification of Jatropha curcas L. oil to biodiesel by a two-step process Energy Conversion and Management 51 12 December 2010 2802 2807
- Xin Deng , Zhen Fang , Yun-hu Liu Production of biodiesel from Jatropha curcas L. oil Computers & Chemical Engineering 33 5 21 May 2009 1091 1096
- Houfang Lu , Yingying Liu , Hui Zhou , Ying Yang , Mingyan Chen , Bin Liang Biodiesel production from crude Jatropha curcas L. seed oil with a high content of freefattyacids Bioresource Technology 99 6 April 2008 1716 1721
- Johanes Berchmans Hanny , Shizuko Hirata Heterogeneous catalysis for biodiesel production from Jatropha curcas oil (JCO) Energy 36 5 May 2011 2693 2700
- Endalew Abebe K. , Yohannes Kiros , Rolando Zanzi Two-step biodiesel production from Jatropha curcas crude oil using SiO2·HF solid catalyst for FFA esterification step Fuel 89 10 October 2010 2815 2821
- Grisel Corro , Nallely Tellez , Edgar Ayala Marinez-Ayal Alma Biodiesel Production from Low Quality Crude Jatropha Oil Using Heterogeneous Catalyst APCBEE Procedia 3 2012 23 27
- Hee Kay Kian , Suhaimi MdYasir Biodiesel production from Jatropha curcas crude oil using ZnO/SiO2 photocatalyst for free fatty acids esterification Applied Catalysis B: Environmental 129 17 January 2013 39 47
- Grisel Corro , Umapada Pal , Nallely Tellez Production of biodiesel from high free fatty acid Karanja(Pongamiapinnata) oil Biomass and Bioenergy 32 4 April 2008 354 357
- Malaya Naik , Meher L.C. , Naik S.N. , Das L.M. Acidcatalyzed esterification of karanja (Pongamiapinnata) oil with high free fatty acids for biodiesel production Fuel 98 August 2012 1 4
- Thiruvengadaravi K.V. , Nandagopal J. , Baskaralingam P. , Bala V. Selva Sathya , Sivanesan S. Development of biodiesel from karanja, a tree found in rural India Fuel 87 8-9 July 2008 1740 1742
- Sharma Y.C. , Singh B. Optimization of two step karanja biodiesel synthesis under microwave irradiation Fuel Processing Technology 92 1 January 2011 100 105
- Venkatesh Kamath H. , Regupathi I. , Saidutta M.B. Methyl ester of karanja oil as an alternative renewable sourc energy Fuel 87 8-9 July 2008 1673 1677
- Srivastava P.K. , Madhumita Verma Biodiesel production from mahua (Madhucaindica) oil having high free fatty acids Biomass and Bioenergy 28 6 June 2005 601 605
- Vilas GhadgeShashikant , Hifjur Raheman Process optimization for biodiesel production from mahua (Madhucaindica) oil using response surface methodology Bioresource Technology 97 3 February 2006 379 384
- Aditi Gupta , Rohit Chaudhary , Satyawati Sharma Potential Applications of Mahua (Madhucaindica) Biomass Waste and Biomass Valorization 3 2 175 189 2012
- Savariraj S. Ganapathy T. and Saravanan C. G. Experimental Investigation of Performance and Emission Characteristics of Mahua Biodiesel in Diesel Engine ISRN Renewable Energy 2011 6 10.5402/2011/405182
- Padhi , S.K. , Singh , R.K. Optimization of esterification and transesterification of Mahua (MadhucaIndica) oil for production of biodiesel J. Chem. Pharm. Res. 2010 2 5 599 608
- Mahua-A potential Treeborne oilseed NOVOD Board, Govt. Of India www.novodboard.com/Mahua-Eng.pdf
- Patil D A , Shubhangi Pawar and Patil M V Mahuwa tree and the aborigines of North Maharashtra Natural Product Radiance 3 5 September October 2004
- http://www.svlele.com/mahuae.htm 10 09 2012
- Agarwal Avinash Kumar , Dhar Atul Experimental investigations of performance, emission and combustion characteristics of Karanja oil blends fuelled DICI engine Renewable Energy 52 2013 283 291
- Chauhan Bhupendra Singh , Kumar Naveen , Cho Haeng Muk A study on the performance and emission of a diesel engine fueled with Jatropha biodiesel oil and its blends Energy 37 2012 616 622
- Devan P.K. , Mahalakshmi N.V. A study of the performance, emission and combustion characteristics of a compression ignition engine using methyl ester of paradise oil-eucalyptus oil blend Applied Energy 86 2009 675 680
- Sahoo P.K. , Das L.M. Combustion analysis of Jatropha, Karanja and Polanga based biodiesel as fuel in a diesel engine Fuel 88 2009 994 999
- Janet Yanowitz , McCormick Robert L. Effect of biodiesel blends on North American heavy-duty diesel engine emissions European Journal of Lipid Science and Technology 111 8 763 772 8 August 2009
- Kent Hoekman S. , Curtis Robbins Review of the effects of biodiesel on NOx emissions Fuel Processing Technology 96 April 2012 237 249
- Kent Hoekmana S. , Amber Brocha , Curtis Robbinsa , Eric Cenicerosa , Mani Natarajanb Review of biodieselcomposition, properties, and specifications Renewable and Sustainable Energy Reviews 16 1 January 2012 143 169
- NurunNabi Md. , Mustafizur Rahman Md. , Shamim Akhter Md. Biodiesel from cotton seed oil and its effect onengine performance and exhaust emissions Applied ThermalEngineering 29 2009 2265 2270
- Godiganur , Sharanappa b Suryanarayana Murthy C.H. , Prathap Reddy Rana 6BTA 5.9 G21 Cummins engineperformance and emission tests using methyl ester mahua(Madhucaindica) oil/diesel blends Renewable Energy 34 2009 2172 2177
- Gvidonas Labeckas , Stasys Slavinskas The effect of rapeseed oil methyl ester on direct injection Diesel engineperformance and exhaust emissions Energy Conversion andManagement 47 2006 1954 1967
- Suresh Kumar K. , Velraj R. , Ganesan R. Performance and exhaust emission characteristics of a CI engine fueled with Pongamiapinnata methyl ester (PPME) and its blendswith diesel Renewable Energy 33 2008 2294 2302
- An H. , Yang W.M. , Chou S.K. , Chua K.J. Combustion and emissions characteristics of diesel engine fueled bybiodiesel at partial load conditions Applied Energy 99 2012 363 371
- Adaileh Wail M. and AlqdahKhaled S. Performance of Diesel Engine Fuelled by a Biodiesel Extracted From AWaste Cocking Oil Energy Procedia 18 2012 1317 1334
- Deepak Agarwal , Lokesh Kumar , Kumar Agarwal Avinash Performance evaluation of a vegetable oil fuelled compressionignition engine Renewable Energy 33 2008 1147 1156
- HoonKiat Ng , Suyin Gan Combustion performance and exhaust emissions from the non pressurised combustion of palm oil biodiesel blends Applied Thermal Engineering 30 2010 2476 2484
- Faletti J , Sorenson S. C. , Goering C. E. Energy release rates from hybrid fuels Transactions of the ASAE 1984 27 2 322 325
- Heywood JB. Internal combustion engine fundamentals New York McGraw-Hill Book Company 1988