This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Surge Noise Identification and Control of Automotive Turbochargers
Technical Paper
2014-01-2053
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The paper describes the identification and control methods of turbocharger surge noise. Some parameters, such as temperature, flow quantity, pressure, vibration, turbocharger rpm and noise, are provided to identify surge noise. The advantages and disadvantages for each parameter are analyzed.
The paper identifies that some special vehicle interior noise is contributed by turbocharger surge noise by using correlation analysis of the turbocharger inlet temperature, outlet pressure and vehicle internal noise. Spectral filtration analysis shows that the surge noise frequency components are above 1000Hz with wide frequency band. Quarter wave tuner's effective frequency range is found to be consistent with the surge noise frequency band. A panfluter-resonator which is a combination of several special quarter wave tuners is invented to diminish the wide band high frequency noise. After the panfluter-resonator is installed on a turbocharger system, the vehicle interior surge noise is significantly reduced.
Recommended Content
Authors
Topic
Citation
Kuang, X., Pang, J., Zhang, H., Yang, L. et al., "Surge Noise Identification and Control of Automotive Turbochargers," SAE Technical Paper 2014-01-2053, 2014, https://doi.org/10.4271/2014-01-2053.Also In
References
- Andersen , J. , Lindström , F. , and Westin , F. Surge Definitions for Radial Compressors in Automotive Turbochargers SAE Int. J. Engines 1 1 218 231 2008 10.4271/2008-01-0296
- Teng , C. and Homco , S. Investigation of Compressor Whoosh Noise in Automotive Turbochargers SAE Int. J. Passeng. Cars - Mech. Syst. 2 1 1345 1351 2009 10.4271/2009-01-2053
- Dehner , R. , Selamet , A. , Keller , P. , and Becker , M. Simulation of Mild Surge in a Turbocharger Compression System SAE Int. J. Engines 3 2 197 212 2010 10.4271/2010-01-2142
- Dehner , R. , Selamet , A. , Keller , P. , and Becker , M. Prediction of Surge in a Turbocharger Compression System vs. Measurements SAE Int. J. Engines 4 2 2181 2192 2011 10.4271/2011-01-1527
- Galindo , J. , Serrano , J , Guardiola , S. , and Cervelló , C Surge limit definition in a specific test bench for the characterization of automotive turbochargers Experimental Thermal and Fluid Science 30 2006 449 462
- Jia , Y , Liu , Z , and Qin , Z. Using Compressor vibration signal to identify the surge Journal of Naval University of Engineering 2000 6 79 81
- Uhlenhake , G. , Selamet , A. , Fogarty , K. , Tallio , K. et al. Development of an Experimental Facility to Characterize Performance, Surge, and Acoustics in Turbochargers SAE Technical Paper 2011-01-1644 2011 10.4271/2011-01-1644
- Greitzer E, M. Surge and Rotating Stall in Axial Flow Compressors ASME J. of Engineering for Power 98 190 198 1976
- Greitzer E, M. Surge and Rotating Stall in Axial Flow Compressors ASME J. of Engineering for Power 98 199 217 1976
- Young , S , Kyu , Y , and Tae , K Introduction of Noise Reduction Examples in Turbocharger System of Diesel Engines FISITA, 2004, 30th Congress
- Galindo , J , Serrano , J , Margot , X , Tiseira , A. et al. Potential of flow pre-whirl at the compressor inlet of automotive engine turbochargers to enlarge surge margin and overcome packaging limitation 247 387 International Journal of Heat and Fluid Flow 28 2007
- Mohtar , H. , Chesse , P. , Yammine , A. , and Hetet , J. Variable Inlet Guide Vanes in a Turbocharger Centrifugal Compressor: Local and Global Study SAE Technical Paper 2008-01-0301 2008 10.4271/2008-01-0301
- Trochon , E. A New Type of Silencers for Turbocharger Noise Control SAE Technical Paper 2001-01-1436 2001 10.4271/2001-01-1436
- Evans , D. and Ward , A. Minimising Turbocharger Whoosh Noise for Diesel Powertrains SAE Technical Paper 2005-01-2485 2005 10.4271/2005-01-2485