This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
A Post-Catalyst Control Strategy Based on Oxygen Storage Dynamics
Technical Paper
2013-01-0352
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
For compliance with future more stringent emission standards exhaust emissions must be reduced. One possibility is to improve air-fuel ratio control quality. The approach presented in this paper uses virtual sensors to get a rough picture of the spatial distribution of lambda and oxygen storage states across the catalyst. This additional process information is gathered by means of a novel model for three-way catalysts. A state-space controller is used to maintain oxygen storage states predicted by the model at desired levels. The proposed control strategy has been implemented on a turbocharged, direct injection engine and successfully validated by means of emission measurements. A comparison with a commonly used air-fuel ratio control strategy is presented.
Authors
Citation
Tomforde, M., Drewelow, W., Duenow, P., Lampe, B. et al., "A Post-Catalyst Control Strategy Based on Oxygen Storage Dynamics," SAE Technical Paper 2013-01-0352, 2013, https://doi.org/10.4271/2013-01-0352.Also In
References
- Jackson , R. , Peyton Jones, J. , Pan , J. , Roberts , J. et al. Chemical Aspects of the Dynamic Performance of a Three-Way Catalyst SAE Technical Paper 1999-01-0312 1999 10.4271/1999-01-0312
- Ohsawa , K. , Baba , N. , and Kojima , S. Numerical Prediction of Transient Conversion Characteristics in a Three-Way Catalytic Converter SAE Technical Paper 982556 1998 10.4271/982556
- Auckenthaler , T.S. Modelling and Control of Three-Way Catalytic Converters Ph.D. thesis Swiss Federal Institute of Technology Zurich 2005
- Brinkmeier , C. , Eigenberger , G. , Büchner , S. , and Donnerstag , A. Transient Emissions of a SULEV Catalytic Converter System Dynamic Simulation vs. Dynamometer Measurements SAE Technical Paper 2003-01-1001 2003 10.4271/2003-01-1001
- Vardi , J. , Biller , W.F. Thermal Behavior of Exhaust Gas Catalytic Convertor Ind. Eng. Chem. Process Des. Dev. 7 83 90 1968 10.1021/i260025a017
- Pattas , K. , Stamatelos , A. , Pistikopoulos , P. , Koltsakis , G. et al. Transient Modeling of 3-Way Catalytic Converters SAE Technical Paper 940934 1994 10.4271/940934
- Koltsakis , G.C. , Konstandinidis , P.A. , Stamatelos , A.M. Development and application range of mathematical models for 3-way catalytic converters Applied Catalysis B: Environmental 12 161 191 1997 10.1016/S0926-3373(96)00073-2
- Koltsakis , G.C. , Kandylas , I.P. , and Stamatelos , A.M. Three-Way Catalytic Converter Modeling and Applications Chemical Engineering Communications 164 153 189 10.1080/00986449808912363
- Braun , J. , Hauber , T. , Többen , H. , Windmann , J. et al. Three-Dimensional Simulation of the Transient Behavior of a Three-Way Catalytic Converter SAE Technical Paper 2002-01-0065 2002 10.4271/2002-01-0065
- Fessler , D.K. Modellbasierte On-Board-Diagnoseverfahren für Drei-Wege-Katalysatoren Ph.D. thesis Karlsruher Institut für Technologie Karlsruhe 2010
- Cornelius , S.J. Modelling and Control of Automotive Catalysts Ph.D. thesis University of Cambridge 2001
- Auckenthaler , T. , Onder , C. , and Geering , H. Online Estimation of the Oxygen Storage Level of a Three-Way Catalyst SAE Technical Paper 2004-01-0525 2004 10.4271/2004-01-0525
- Glielmo , L. , Santini , S. , and Serra , G. A Two-Time-Scale Infinite-Adsorption Model of Three Way Catalytic Converters Proceedings of the American Control Conference 1999 10.1109/ACC.1999.786557
- Roduner , C.A. , Onder , C.H. , and Geering , H.P. Automated Design of an air/fuel controller for an SI engine considering the three-way catalytic converter in the H ∞ approach 5 th Mediterranean Conference on Control Systems 1997
- Shafai , E. , Roduner , C. , and Geering , H. Indirect Adaptive Control of a Three-Way Catalyst SAE Technical Paper 961038 1996 10.4271/961038
- Ammann , M , Geering , H.P. , Onder , C.H. , Roduner , C.A. , and Shafai , E. Adaptive Control of a Three-Way Catalytic Converter Proceedings of the American Control Conference 2000 10.1109/ACC.2000.879463
- Brandt , E.P. , Wang , Y. , and Grizzle , J.W. A Simplified Three-Way Catalyst Model for Use in On-Board SI Engine Control and Diagnostics ASME Dynamic Systems and Control 1997
- Brandt , E.P. , Wang , Y. , and Grizzle , J.W. Dynamic Modeling of a Three-Way Catalyst for SI Engine Emission Control IEEE Transactions on Control System Technology 8 767 776 2000 10.1109/87.865850
- Cioffi , V. , Scala , S. , and Sepe , E. Control Oriented Modeling of the Exhaust Gas After-Treatment System MECA01 International Workshop on Modeling, Emissions and Control of Automotive Engines 2001
- Caraceni , A. , Di Mare , G. , Ferrara , F. , Scala , S. , and Sepe , E. Hardware in the Loop Testing of EOBD Strategies 15 th IFAC Triennial World Congress 2002 10.3182/20020721-6-ES-1901.01501
- Fiengo , G. , Glielmo , L. , Santini , S. , and Caraceni , A. A Fault Diagnosis Algorithm for Three-Way Catalytic Converters 5 th International Symposium on Advanced Vehicle Control 2000
- Fiengo , G. , Glielmo , L. , and Santini , S. On-board diagnosis for three-way catalytic converters International Journal of Robust and Nonlinear Control 11 1073 1094 2001 10.1002/rnc.645
- Fiengo , G. Emissions Control for the Spark Ignition Internal Combustion Engine equipped with Three-Way Catalytic Converter Ph.D. thesis Universita degli Studi di Napoli Federico II Naples 2001
- Fiengo , G. , Glielmo , L. , Santini , S. , and Serra , G. Control Oriented Models for TWC equipped Spark Ignition Engines during Warm-Up Phase Proceedings of the American Control Conference 2002 10.1109/ACC.2002.1023821
- Balenovic , M. , Backx , A. , and Hoebink , J. On a Model-Based Control of a Three-Way Catalytic Converter SAE Technical Paper 2001-01-0937 2001 10.4271/2001-01-0937
- Balenovic , M. , Backx , T. , and de Bie , T. Development of a Model-Based Controller for a Three-Way Catalytic Converter SAE Technical Paper 2002-01-0475 2002 10.4271/2002-01-0475
- Balenovic , M. Modeling and Model-Based Control of a Three-Way Catalytic Converter Ph.D. thesis Technische Universiteit Eindhoven Eindhoven 2002
- Peyton Jones , J. , Roberts , J. , Bernard , P. , and Jackson , R. A Simplified Model for the Dynamics of a Three-Way Catalytic Converter SAE Technical Paper 2000-01-0652 2000 10.4271/2000-01-0652
- Peyton Jones , J. Modeling Combined Catalyst Oxygen Storage and Reversible Deactivation Dynamics for Improved Emissions Prediction SAE Technical Paper 2003-01-0999 2003 10.4271/2003-01-0999
- Watanabe , T. , Watanabe , Ta. , Abe , K. , Yoshizawa , H. Parameter Identification of 3-Way Catalytic Converter for Use in Air Fuel Ratio Control SICE Annual Conference 2004
- Tomforde , M. Vergleich von Modellierungsansätzen für Dreiwege-Katalysatoren unter dem Gesichtspunkt einer modellbasierten Regelung Master Thesis Hochschule Wismar Wismar 2009
- Tomforde , M. Three-way catalyst models for oxygen storage based control of the air-fuel ratio XI International PhD Workshop OWD Poland October 17 20 2009
- Shulman , M. and Hamburg , D. Non-Ideal Properties of ZrO 2 and TiO 2 Exhaust Gas Oxygen Sensors SAE Technical Paper 800018 1980 10.4271/800018
- Colvin , A.D. , Butler , J.W. , and Anderson , J.E. Catalytic Effects on ZrO2 Oxygen Sensors Exposed to Non-Equilibrium Gas Mixtures J. Electroanal. Chem. 136 1 179 183 1982 10.1016/0022-0728(82)87032-0
- Fiengo , G. , Cook , J.A. , and Grizzle , J.W. Fore-Aft Oxygen Storage Control Proceedings of the American Control Conference 2001 10.1109/ACC.2002.1023217
- Muske , K.R. , and Peyton Jones , J.C. Multi-objective model-based control for an automotive catalyst Journal of Process Control 16 27 35 2006 10.1016/j.jprocont.2005.04.008